|
|
|
| Anomaly detection using wavelet residual network for pump valves via transfer learning under variable operating conditions |
Xiao WU1( ),Mingxuan ZHANG3,Zhiye HE1,Feng LUO1,Guojin SI1,Tangbin XIA1,2,*( ) |
1. School of Mechanical Engineering, Shanghai Jiao Tong University, Shanghai 200240, China 2. Special Environment Digital Manufacturing Equipment Technology Innovation Center, Mianyang 621900, China 3. Petromentor Intelligence Safe Technology (Beijing) Limited Company, Beijing 100012, China |
|
|
|
Abstract A wavelet residual network-based anomaly detection method for transfer learning under variable operating conditions was proposed to address the insufficient generalization performance of fracturing pump valve anomaly detection caused by dynamically varying operating conditions. A multi-branch residual network incorporating wavelet convolution was constructed to extract discriminative fault features from vibration signals. A multi-branch squeeze-and-excitation attention mechanism was utilized to adaptively recalibrate the channels of key fault features, thereby enhancing feature representation capability. A trainable projected gradient method was adopted to minimize the distribution discrepancy between source and target domains, improving the transfer effectiveness and generalization performance of the model under variable operating conditions. The proposed method was validated using vibration data collected from pump valves of fracturing pumps in a real oilfield environment. The experimental results demonstrated that the proposed method achieved a detection accuracy of 99.51%, outperforming existing state-of-the-art methods by more than 1.73%, and exhibited favorable robustness and generalization capability under variable operating conditions.
|
|
Received: 08 December 2025
Published: 21 October 2026
|
|
|
| Fund: 国家自然科学基金资助项目(72571173,72401187);上海市自然科学基金资助项目(25ZR1401196);国家重点研发计划资助项目(2022YFF0605700). |
|
Corresponding Authors:
Tangbin XIA
E-mail: wu1217@sjtu.edu.cn;xtbxtb@sjtu.edu.cn
|
面向变工况迁移学习的泵阀小波残差网络异常检测
针对压裂泵泵阀异常检测中因工况动态变化导致的泛化性不足问题,提出面向变工况迁移学习的泵阀小波残差网络异常检测方法. 构建融入小波卷积的多分支残差网络故障特征提取器,从采集的振动信号中提取关键故障特征. 利用多分支挤压激励注意力机制对关键故障特征通道进行自适应权重校准,增强关键故障特征的表征能力. 采用可训练的投影梯度方法来最小化源域与目标域间的分布差异,优化模型在变工况条件下的迁移效果,增强模型的泛化性能. 使用某油田实际作业现场采集的压裂泵泵阀振动数据进行效果验证,实验结果表明,所提方法的检测准确率可达99.51%,较现有先进模型提升1.73%以上,在变工况条件下具有优异的鲁棒性和泛化性能.
关键词:
迁移学习,
小波卷积,
残差网络,
注意力机制,
异常检测
|
|
| [1] |
Lu C, Wang Z, Zhou B Intelligent fault diagnosis of rolling bearing using hierarchical convolutional network based health state classification[J]. Advanced Engineering Informatics, 2017, 32: 139- 151
doi: 10.1016/j.aei.2017.02.005
|
|
|
| [2] |
Li Congyue, Hu Yihui, Jiang Jiawei, et al Fault diagnosis of marine diesel generators based on gram angle fields and convolutional neural networks[J]. Journal of Zhejiang University: Science A (Applied Physics and Engineering), 2024, 25 (6): 470- 482
|
|
|
| [3] |
Fink O, Wang Q, Svensén M, et al Potential, challenges and future directions for deep learning in prognostics and health management applications[J]. Engineering Applications of Artificial Intelligence, 2020, 92: 103678
doi: 10.1016/j.engappai.2020.103678
|
|
|
| [4] |
周姿含, 王叙萌, 陈为 基于迁移学习的交互时序数据可视化生成方法[J]. 浙江大学学报(工学版), 2024, 58 (2): 239- 246 Zhou Zihan, Wang Xumeng, Chen Wei Interactive visualization generation method for time series data based on transfer learning[J]. Journal of Zhejiang University(Engineering Science), 2024, 58 (2): 239- 246
doi: 10.3785/j.issn.1008-973X.2024.02.002
|
|
|
| [5] |
Wang P, Zhang Y, Linjama M, et al Fault identification and localization for the fast switching valve in the equal-coded digital hydraulic system based on hybrid CNN-LSTM model[J]. Mechanical Systems and Signal Processing, 2025, 224: 112201
doi: 10.1016/j.ymssp.2024.112201
|
|
|
| [6] |
吴泽林, 罗风, 崔曦文, 等 融合深度学习的油田柱塞式注水泵不平衡数据故障诊断方法[J]. 上海交通大学学报, 2026, 60 (6): 1017- 1025 Wu Zelin, Luo Feng, Cui Xiwen, et al A deep learning-based fault diagnosis method for unbalanced data in oilfield plunger-type water injection pumps[J]. Journal of Shanghai Jiao Tong University, 2026, 60 (6): 1017- 1025
doi: 10.16183/j.cnki.jsjtu.2024.308
|
|
|
| [7] |
Wang J, Zhang X, Zhang Z, et al Attention guided multi-wavelet adversarial network for cross domain fault diagnosis[J]. Knowledge-Based Systems, 2024, 284: 111285
doi: 10.1016/j.knosys.2023.111285
|
|
|
| [8] |
崔曦文, 许昱晖, 吴泽林, 等. 融合度量学习与采样适应机制的注水泵数据不平衡故障诊断[J/OL]. 上海交通大学学报, 2025-03-26. https://doi.org/10.16183/j.cnki.jsjtu.2024.442. Cui Xiwen, Xu Yuhui, Wu Zelin, et al. Data imbalanced fault diagnosis of water injection pumps integrating metric learning and adaptive sampling mechanisms [J/OL]. Journal of Shanghai JiaoTong University, 2025-03-26. https://doi.org/10.16183/j.cnki.jsjtu.2024.442.
|
|
|
| [9] |
Liang H, Cao J, Zhao X Multibranch and multiscale dynamic convolutional network for small sample fault diagnosis of rotating machinery[J]. IEEE Sensors Journal, 2023, 23 (8): 8973- 8988
doi: 10.1109/JSEN.2023.3255203
|
|
|
| [10] |
An Z, Li S, Wang J, et al A novel bearing intelligent fault diagnosis framework under time-varying working conditions using recurrent neural network[J]. ISA Transactions, 2020, 100: 155- 170
doi: 10.1016/j.isatra.2019.11.010
|
|
|
| [11] |
Wu Y, Ma X A hybrid LSTM-KLD approach to condition monitoring of operational wind turbines[J]. Renewable Energy, 2022, 181: 554- 566
doi: 10.1016/j.renene.2021.09.067
|
|
|
| [12] |
Dao F, Zeng Y, Qian J Fault diagnosis of hydro-turbine via the incorporation of Bayesian algorithm optimized CNN-LSTM neural network[J]. Energy, 2024, 290: 130326
doi: 10.1016/j.energy.2024.130326
|
|
|
| [13] |
Ali Y M, Ding L, Qin S An efficient approach for diagnosing faults in photovoltaic array using 1D-CNN and feature selection techniques[J]. International Journal of Electrical Power and Energy Systems, 2025, 166: 110526
doi: 10.1016/j.ijepes.2025.110526
|
|
|
| [14] |
郭俊锋, 王淼生, 王智明 基于对不平衡数据集进行二次迁移学习的滚动轴承剥落类故障诊断方法[J]. 上海交通大学学报, 2023, 57 (11): 1512- 1521 Guo Junfeng, Wang Miaosheng, Wang Zhiming Fault diagnosis of rolling bearing with roller spalling based on two-step transfer learning on unbalanced dataset[J]. Journal of Shanghai JiaoTong University, 2023, 57 (11): 1512- 1521
doi: 10.16183/j.cnki.jsjtu.2022.008
|
|
|
| [15] |
Dai M, Liu Z, Wang J, et al Physics-driven feature alignment combined with dynamic distribution adaptation for three-cylinder drilling pump cross-speed fault diagnosis[J]. Reliability Engineering and System Safety, 2024, 251: 110369
doi: 10.1016/j.ress.2024.110369
|
|
|
| [16] |
Ding Y, Jia M, Zhuang J, et al Deep imbalanced domain adaptation for transfer learning fault diagnosis of bearings under multiple working conditions[J]. Reliability Engineering and System Safety, 2023, 230: 108890
doi: 10.1016/j.ress.2022.108890
|
|
|
| [17] |
Bang J, Di Marco P, Shin H, et al Deep transfer learning-based fault diagnosis using wavelet transform for limited data[J]. Applied Sciences, 2022, 12 (15): 7450
doi: 10.3390/app12157450
|
|
|
| [18] |
耿志强, 陈威, 马波, 等 基于连续小波卷积神经网络的轴承智能故障诊断方法[J]. 浙江大学学报(工学版), 2024, 58 (10): 2069- 2075 Geng Zhiqiang, Chen Wei, Ma Bo, et al Bearing intelligent fault diagnosis method based on continuous wavelet convolutional neural network[J]. Journal of Zhejiang University (Engineering Science), 2024, 58 (10): 2069- 2075
doi: 10.3785/j.issn.1008-973X.2024.10.010
|
|
|
| [19] |
Yang Z, Zhu L, Wu Y, et al. Gated channel transformation for visual recognition [C]//Proceedings of the IEEE/CVF Conference on Computer Vision and Pattern Recognition. Seattle: IEEE, 2020: 11791–11800.
|
|
|
| [20] |
Tian J, Dai X, Ma C Y, et al. Trainable projected gradient method for robust fine-tuning [C]//Proceedings of the IEEE/CVF Conference on Computer Vision and Pattern Recognition. Vancouver: IEEE, 2023: 7836–7845.
|
|
|
| [21] |
Shan L, Liu Y, Tang M, et al CNN-BiLSTM hybrid neural networks with attention mechanism for well log prediction[J]. Journal of Petroleum Science and Engineering, 2021, 205: 108838
doi: 10.1016/j.petrol.2021.108838
|
|
|
| [22] |
Zhu Y, Zhuang F, Wang J, et al Deep subdomain adaptation network for image classification[J]. IEEE Transactions on Neural Networks and Learning Systems, 2021, 32 (4): 1713- 1722
doi: 10.1109/TNNLS.2020.2988928
|
|
|
| [23] |
Ganin Y, Ustinova E, Ajakan H, et al. Domain-adversarial training of neural networks [M]//Domain adaptation in computer vision applications. Cham: Springer, 2017: 189–209.
|
|
|
| [24] |
Chadha A, Andreopoulos Y Improved techniques for adversarial discriminative domain adaptation[J]. IEEE Transactions on Image Processing, 2020, 29: 2622- 2637
doi: 10.1109/TIP.2019.2950768
|
|
|
| [25] |
Wei D, Han T, Chu F, et al Weighted domain adaptation networks for machinery fault diagnosis[J]. Mechanical Systems and Signal Processing, 2021, 158: 107744
doi: 10.1016/j.ymssp.2021.107744
|
|
|
|
Viewed |
|
|
|
Full text
|
|
|
|
|
Abstract
|
|
|
|
|
Cited |
|
|
|
|
| |
Shared |
|
|
|
|
| |
Discussed |
|
|
|
|