Please wait a minute...
浙江大学学报(工学版)
能源与环境工程     
低氮煤粉旋流燃烧器火焰特性的研究
周昊, 马炜晨,  杨玉, 陈建中
浙江大学 能源清洁利用国家重点实验室,浙江 杭州 310027
Investigation of flame characteristics of low NOx swirl burner
ZHOU Hao, MA Wei chen, YANG Yu, CHEN Jian zhong
State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China
 全文: PDF(1350 KB)   HTML
摘要:

为了研究实际炉膛中旋流燃烧器火焰的特点,采用火焰拍摄系统和抽气测温系统对一台600 MW电站锅炉上的低氮旋流燃烧器的火焰进行详细的测量,分析该低氮旋流燃烧器的火焰形状、轴向的组分和温度分布、火焰亮度及温度随标高的分布规律等.研究结果表明:该旋流燃烧器火焰的扩展角约为60°,火焰的直径从燃烧器喷口到下游呈现先增大后减小的特点,最大直径约为1.25 m,在距离燃烧器喷口约1.6 m处,火焰直径达到一个极小值,这是因为二次风从该位置开始混入一次风.旋流燃烧器火焰的中心区域为带粉的一次风占据,一次风中煤粉在喷入炉膛1.3 m以后开始着火.旋流燃烧器喷口附近的火焰为回流区带回的挥发份与二次风接触后燃烧产生.该燃烧器火焰从内到外依次可以分为一次风区域、回流区、高温火焰区和二次风区.炉膛内燃烧器火焰的亮度和温度随标高的变化特征是先升高后降低,在第三层燃烧器标高处达到最大值.

Abstract:

A flame monitoring system and an air extracting system were used to measure eight swirl burners arranged close to a side wall of a 600 MW pulverized coal utility boiler in order to analyze the flame characteristics of swirl burners. The size of flame, temperature distribution and gas compositions along the axis of the burner, flame brightness and temperature along the elevation were analyzed. Results showed that the expansion angle of the burner flame was about 60°. The diameter of the flame increased firstly and then decreased downstream from the burner outlet, and the maximum diameter was about 1.25 m. The flame diameter reached a minimum value about 1.6 m from the burner outlet, where the secondary air became to mix with the primary air. The central region of the flame was occupied by the primary air with coal particles, which were ignited about 1.3 m downstream of the burner outlet. The peripheral high temperature region was the result of the combustion of volatiles brought back by the recirculation region. Both the brightness and temperature of the flame in the furnace firstly increased and then decreased with the increasing of the elevation. The maximum value of the brightness and temperature emerged at the third layer of burners.

出版日期: 2016-04-01
:  TK 0  
基金资助:

国家“973”重点基础研究发展规划资助项目(2015CB251501).

作者简介: 周昊( 1973-), 男, 教授, 博导, 从事煤的低污染优化燃烧技术研究. ORCID: 0000 0001 9779 7703. E-mail: zhouhao@cmee.zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

周昊, 马炜晨, 杨玉, 陈建中. 低氮煤粉旋流燃烧器火焰特性的研究[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2016.04.014.

ZHOU Hao, MA Wei chen, YANG Yu, CHEN Jian zhong. Investigation of flame characteristics of low NOx swirl burner. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2016.04.014.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2016.04.014        http://www.zjujournals.com/eng/CN/Y2016/V50/I4/698

[1] ZHOU H, YANG Y, LIU H, et al. Numerical simulation of the combustion characteristic of a low NOx swirl burner: influence of the primary air pipe [J]. Fuel, 2014, 130: 168-176.
[2] JAVIER B, TATIANA G. Diagnostic techniques for the monitoring and control of practical flames [J]. Progress in Energy and Combustion Science, 2010, 36(4):375-411.
[3] JING J, LI Z, CHEN Z, et al. Study of the influence of vane angle on flow, gas species, temperature, and char burnout in a 200 MWe lignite fired boiler [J]. Fuel, 2010, 89(8): 1973-1984.
[4] GODOY S, HIRJI K A, LOCKWOOD F C. Combustion measurements in a pulverized coal fired furnace [J]. Combustion Science and Technology, 1988, 59(13): 165-182.
[5] ZHOU H, REN T, HUANG Y, et al. Low NOx modification of a heavy fuel oil swirl burner based on semi industrial scale experimental tests [J]. Energy and Fuels, 2013, 27(9): 5029-5035.
[6] YAN Y, LU G, COLECHIN M. Monitoring and characterization of pulverized coal flames using digital imaging technique [J]. Fuel, 2002, 81(5): 647-655.
[7] LU G, YAN Y, CORNWELL S, et al. Impact of co firing coal and biomass on flame characteristics and stability [J]. Fuel, 2008, 87(7): 1133-1140.
[8] MOLCAN P, LU G, LE BRIS T, et al. Characterisation of biomass and coal co firing on a 3 MWth combustion test facility using flame imaging and gas/ash sampling techniques [J]. Fuel, 2009, 88(12): 2328-2334.
[9] ZHOU H, LOU C, CHEN Q, et al. Experimental investigations on visualization of three dimensional temperature distributions in a large scale pulverized coal fired boiler furnace [J]. Proceedings of the combustion Institute, 2005, 30: 1699-1706.
[10] JIANG Z, LUO Z, ZHOU H. A simple measurement method of temperature and emissivity of coal fired flames from visible radiation image and its application in a CFB boiler furnace [J]. Fuel, 2009, 88(6):980-987.
[11] 周昊,林阿平,周斌,等.基于图像处理的灰渣温度场及生长特性[J].浙江大学学报:工学版, 2013, 47(4): 669-674.
ZHOU Hao, LIN A ping, ZHOU Bin, et al. Characteristic of ash deposit growth and temperature field by image processing [J]. Journal of Zhejiang University: Engineering Science, 2013, 47(4): 669-674.
[12] PAUL GOTHE BOCHUM. Manual for pyrometer [EB/OL]. 2015 02 12. http:∥www.paulgothe.de.
[13] 汤琪.基于数字图像的火焰测量及煤质识别[D].杭州: 浙江大学, 2014.
TANG Qi. Flame measurement and coal identification based on digital image [D]. Hangzhou: Zhejiang University, 2014.

[1] 黄子硕, 于航, 彭震伟, 刘志渊. 面向社区能源规划的建筑总能系统模型[J]. 浙江大学学报(工学版), 2016, 50(2): 292-298.
[2] 张旭,刘建忠,吴君宏,赵琛杰,周俊虎,岑可法. 水分随煤阶及水热变化的核磁共振研究[J]. 浙江大学学报(工学版), 2016, 50(1): 123-128.
[3] 张雷, 潘存云, 徐海军, 张湘. 旋转活塞式气动发动机气口设计[J]. 浙江大学学报(工学版), 2014, 48(12): 2181-2187.
[4] 纪莎莎, 李晓东, 俞明锋, 任咏, 陈彤, 王智化, 岑可法. V2O5-WO3/TiO2催化剂降解气相二恶英的研究[J]. 浙江大学学报(工学版), 2014, 48(10): 1746-1751.
[5] 李延吉,邹科威,姜璐,李润东,池涌,岑可法. 垃圾衍生燃料焚烧污染物排放实验与模拟[J]. 浙江大学学报(工学版), 2014, 48(7): 1254-1259.
[6] 霍新新,褚金奎,韩冰峰,姚斐.  基于多个压电换能器的接口电路[J]. J4, 2013, 47(11): 2038-2045.
[7] 李延吉,姜璐,邹科威,赵宁,李玉龙,李润东,池涌.  基于aspen plus的垃圾衍生燃料热解模拟与实验[J]. J4, 2013, 47(9): 1637-1643.
[8] 李延吉, 姜璐, 赵宁, 李玉龙, 李润东, 池涌. 垃圾衍生燃料富氧燃烧污染物排放特性[J]. J4, 2013, 47(2): 314-318.
[9] 周懿, 钟崴, 谢金芳, 童水光. 过程型机械系统的方案设计模型[J]. J4, 2012, 46(8): 1526-1533.
[10] 夏巧民, 胡亚才. 溴化锂储热储冷系统[J]. J4, 2011, 45(10): 1804-1808.