Please wait a minute...
J4  2013, Vol. 47 Issue (2): 314-318    DOI: 10.3785/j.issn.1008-973X.2013.02.019
能源工程     
垃圾衍生燃料富氧燃烧污染物排放特性
李延吉1,2, 姜璐1, 赵宁1, 李玉龙1, 李润东1, 池涌2
1.沈阳航空航天大学清洁能源辽宁省重点实验室,辽宁 沈阳 110136;
2. 浙江大学 能源清洁利用国家重点实验室,浙江 杭州 310027LI
Pollutants emission characteristics of refuse derived fuel in
oxygenenriched combustion
Yan-ji1,2, JIANG Lu1, ZHAO Ning1, LI Yu-long1, LI Run-dong1, ChI Yong2
1. Clean Energy Key Laboratory of Liaoning, Shenyang Aerospace University, Shenyang 110136, China;
2. State Key Laboratory Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China
 全文: PDF  HTML
摘要:

为了解决城市生活垃圾直接焚烧产生的二次污染问题,将城市生活垃圾制成垃圾衍生燃料(RDF),在高温管式炉内进行富氧燃烧污染物排放特性研究.结果表明: 塑料比例增加,燃烧过程中NOx浓度增大;氧浓度增加,NOx浓度增大;但纯氧条件下RDF燃烧,NOx浓度大大降低.塑料比例增加,燃烧过程中SO2浓度增大;氧浓度增加,SO2浓度降低.当氧浓度为80%时,CO浓度相差不大,纯氧时,塑料比例增大,CO浓度减小;氧浓度增大,CO浓度呈减小趋势,纯氧时CO浓度最小.NOx、SO2、CO的浓度均低于国家标准,说明RDF富氧燃烧有利于降低污染物排放浓度.

Abstract:

 Combustion and emission characteristics of refuse derived fuel ( RDF ) were experimental studied in a tubular high temperature furnace. The results showed that: 1 The increase of plastic proportion in RDF and oxygen concentration in combustion air lead the increase of NOx emission; but under the pure oxygen environment of RDF combustion, NOx emission is greatly reduced; 2 SO2 concentration increases with increasing plastic proportion in RDF and oxygen concentration in combustion air,; 3 Oxygen concentration in combustion air does not have significance effect on CO emission when it is less than 80% in oxygen-enriched combustion,. In pure oxygen combustion, increasing the plastic ratio can reduce the CO emissions; CO emissions tended to decrease with increasing oxygen concentration, CO emissions is minimum in pure oxygen condition; 4 The emissions of NOx, SO2 and CO are lower than national standard, which indicated that the RDF combustion with oxygen enrichment is beneficial for the c pollutant emissions reduction.

出版日期: 2013-02-01
:  TK 09  
基金资助:

 国家重点基础研究发展计划资助项目(2011CB201500);国家水重大专项课题资助项目(2008ZX07313-006);辽宁省创新团队资助项目(2009T078).

通讯作者: 池涌, 男, 教授.     E-mail: chiyong@zju.edu.cn
作者简介: 李延吉(1974—),男,副教授,博士生,从事专业为工程热物理.E-mail: yanji0518@163.com
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

李延吉, 姜璐, 赵宁, 李玉龙, 李润东, 池涌. 垃圾衍生燃料富氧燃烧污染物排放特性[J]. J4, 2013, 47(2): 314-318.

Yan-ji, JIANG Lu, ZHAO Ning, LI Yu-long, LI Run-dong, ChI Yong. Pollutants emission characteristics of refuse derived fuel in
oxygenenriched combustion. J4, 2013, 47(2): 314-318.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2013.02.019        http://www.zjujournals.com/eng/CN/Y2013/V47/I2/314

[1] 王志奇,陈勇.垃圾衍生燃料等温快速热解和燃烧反应特性[J].燃料化学学报,2004(32): 441-444.
WANG Zhi-qi,CHEN Yong. Pyrolysis and combustion characteristics of RDF at isothermal condition [J]. Journal of Fuel Chemistry and Technology,2004(32): 441-444.
[2] 米翠丽,阎维平.增压富氧燃烧烟气辐射特性宽带关联k模型[J].中国电机工程学报,2010,30(29): 62-68.
MI Cui-li,YAN Wei-ping. A wide band correlated-k distribution model for the gas radiative property under pressurized oxygenenriched combustion [J]. Proceedings of the CSEE, 2010,30(29): 62-68.
[3] GALVGNO, S, CASU, S, CASCIARO, G., et al. Steam gasification of refuse-derived fuel (RDF): influence of process temperature on yield and product composition [J]. Energy & Fuels, 2008,2284-2288.
[4] LIU H,ZAI LANI R,GIBBS B M. Pulverized coal combustion in air andin O2/CO2 mixtures with NOx recycle[J].Fuel,2005,84 (17): 2109-2115.
[5] HU Y, NATIO S, OBAY ASHI N. CO2, NOx and SO2 emissions from the combustion of coal with high oxygen concentration gases [J]. Fuel,2000,79 (15): 1925-1932.
[6] BINLIN D, SANGUK P, SUNGJIN L, et al. Pyrolysis characteristics of refuse derived fuel in a pilotscale unit[J]. Energy & Fuels, 2007, 21(6): 3730-3734.
[7] SHARMA R K, WOOTEN J B, BALIGA V L, et al. Characterization of chars from pyrolysis of lignin[J]. Fuel, 2004, 83(1): 59-64.
[8] MARSH R, GRIFFITHS A J, WILLIAMS K P, et al. Physical and thermal properties of extruded refuse derived fuel [J]. Fuel Processing Technology, 2007, 88(7): 701-706.
[9] WAN Hanping, CHANG Ying-hai, CHEN Wen-cheng, et al. Emissions during co-firing of RDF-5 with bituminous coal, paper sludge and waste tires in a commercial circulating fluidized bed co-generation boiler [J]. Fuel, 2007, 6(4): 1-7.
[10] BINLIN D, SANGUK P, SUNGJIN, et al. Pyrolysis characteristics of refuse derived fuel in a pilotscale unit[J]. Energy & Fuels, 2007, 21: 3730-3734.
[11] FU Zhi-min, LI Xin-rui, HIROSHI K. Heat generation of refuse derived fuel with water[J]. Journal of Loss Prevention in the Process Industries,2005: 28-32.
[12] 何宏舟,邹峥,俞金树,等.循环流化床锅炉燃烧福建无烟煤炉内脱硫的工业试验研究[J].中国电机工程学报,2010,30(35): 7-12
HE Hong-zhou,ZOU Zheng,YU Jin-shu,et al. An industrial experiment research on the desulfurization of circulating fluidized bed boiler burning fujian anthracite [J]. Proceedings of the CSEE, 2010,30(35): 7-12
[13] 樊盛越,邹峥,高巨宝,等.富氧气氛中煤粉燃烧特性改善的实验研究[J].西安交通大学学报,2006, 40(1): 18-21.
FAN Sheng-yue,Zou Zheng,GAO Ju-bao,et al. Experimental research of rich oxygen content on improving combustion characteristics of pulverized coal [J]. Journal of Xi an Jiaotong University,2006, 40(1): 18-21.

[1] 李延吉,姜璐,邹科威,赵宁,李玉龙,李润东,池涌.  基于aspen plus的垃圾衍生燃料热解模拟与实验[J]. J4, 2013, 47(9): 1637-1643.