Please wait a minute...
J4  2011, Vol. 45 Issue (7): 1259-1264    DOI: 10.3785/j.issn.1008-973X.2011.07.020
机械与能源工程     
路面激励下车辆悬架滞回模型的混沌研究
吴参1,2,3,王维锐4,徐博侯5,李兴林3,江伟光6
1. 浙江大学 工业设计所,浙江 杭州 310027;2. 杭州电子科技大学 机械工程学院,浙江 杭州 310018;
3. 杭州轴承试验研究中心有限公司,浙江 杭州 310022;4. 浙江大学 机械设计所,浙江 杭州 310027;
5. 浙江大学 航空航天学院,浙江 杭州 310027;6. 浙江工业大学 机械工程学院,浙江 杭州 310014
Chaotic behavior of hysteretic suspension model
excited by road surface profile
WU Can1,2,3,WANG Wei-rui4,XU Bo-hou5,LI Xing-lin3,JIANG Wei-guang6
1. Institute of Industrial Design, Zhejiang University, Hangzhou 310027, China; 2. School of Mechanical Engineering,
Hangzhou Dianzi University, Hangzhou 310018, China; 3. Hangzhou Bearing Test and Research Center,
Hangzhou 310022, China; 4. Institute of Mechanical Design, Zhejiang University, Hangzhou 310027, China;5. School of
Aeronautics and Astronautics, Zhejiang University, Hangzhou 310027, China; 6. School of Mechanical Engineering,
Zhejiang University of Technology, Hangzhou 310014, China
 全文: PDF  HTML
摘要:

为了分析车辆悬架在实际路面激励下的振动状态,根据试验所得的磁流变减振器示功曲线,采用Matlab软件拟合修正的BoucWen模型,建立带滞回特性的非线性模型以及基于减振器试验数据的两自由度四分之一悬架模型.研究该半主动悬架的频率响应特性,通过相平面图、Poincaré截面图和分叉图分析半主动悬架在不同路面激励下的振动形式,研究随着路面变化或者悬架自身参数变化引起的振动形式的改变,揭示悬架系统在各种工况下发生的混沌行为,为地面车辆的动力学设计提供依据.

Abstract:

The indicator diagram of magneto-rheological fluid damper was collected from experiments in order to analyze the vibration status of vehicle suspension under practical road profile. Then a modified Bouc-Wen model, which was a nonlinear model with hysteretic loop, was conducted by Matlab according to the experimental data. The model of semitest two degree of freedom a quarter suspension was established. The frequency response characteristics of the model were analyzed, and the nonlinear characteristics were indicated in amplitudefrequency characteristic curves. The vibration form under different road excitation was judged by phase portrait, Poincaré diagram and bifurcate diagram, and the transfer of vibration form was influenced by either pavement excitation, or damping and stiffness of suspension. Results indicate the chaotic behavior under variable situations and provide the basis for the dynamic design of ground vehicle.

出版日期: 2011-07-01
:  O 328  
基金资助:

国家自然科学基金资助项目(51005206);浙江省自然科学基金资助项目(Y1111044);杭州电子科技大学科研基金资助项目(KYF015610027);启动基金资助项目(KYS015611017).

通讯作者: 王维锐,男,助理研究员.     E-mail: wwrzju@126.com
作者简介: 吴参(1982-), 男, 讲师, 博士后,从事汽车零部件、非线性振动研究. E-mail:notemple@gmail.com
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
作者相关文章  

引用本文:

吴参,王维锐,徐博侯,李兴林,江伟光. 路面激励下车辆悬架滞回模型的混沌研究[J]. J4, 2011, 45(7): 1259-1264.

WU Can,WANG Wei-rui,XU Bo-hou,LI Xing-lin,JIANG Wei-guang. Chaotic behavior of hysteretic suspension model
excited by road surface profile. J4, 2011, 45(7): 1259-1264.

链接本文:

https://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2011.07.020        https://www.zjujournals.com/eng/CN/Y2011/V45/I7/1259

[1] 胡玉梅,邓兆祥,王欣.汽车后悬架的非线性有限元分析[J].重庆大学学报,2003,26(4): 38-41.
HU Yumei,DENG Zhaoxiang,WANG Xin. The nonlinear FEA of vehicle rear suspension [J]. Journal of Chongqing University,2003,26(4): 38-41.
[2] SUNG K J,HAN Y M,CHO J W,et al. Vibration control of vehicle ER suspension system using fuzzy moving sliding mode controller [J]. Journal of Sound and Vibration, 2008, 311(3/4/5):1004-1019.
[3] 王维锐,吴参,潘双夏,等. 车辆半主动悬架负刚度控制策略研究[J]. 浙江大学学报:工学版,2009,43 (6):1129-1133.
WANG Weirui, WU Can, PAN Shuangxia, et al. Negative stiffness based control strategy of vehicle semiactive suspension [J]. Journal of Zhejiang University: Engineering Science,2009,43 (6):1129-1133.
[4] YAGIZ N, HACIOGLU Y. Backstepping control of a vehicle with active suspensions [J]. Control Engineering Practice, 2008, 16(12): 1457-1467.

[5] YU M, DONG X M, CHOI S B, et al. Human simulated intelligent control of vehicle suspension system with MR dampers [J]. Journal of Sound and Vibration, 2009, 319(3/4/5): 753-767.
[6] DU H P,KAM Y S,LAM J. Semiactive H∞ control of vehicle suspension with magnetorheological dampers [J]. Journal of Sound and Vibration, 2005, 283(3/4/5):981-996.
[7] 汪若尘,江浩斌,张效良,等.阻尼非线性半主动悬架的建模与控制[J].农业机械学报,2008,39(12):14-17.
WANG Ruochen, JIANG Haobin, ZHANG Xiaoliang, et al. Modeling and control of semiactive suspension with nonlinear damping [J]. Transactions of the Chinese Society of Agricultural Machinery,2008,39(12):14-17.
[8] GRZEGORZ L, MAREK B, MICHEAL I F, et al. Chaotic vibration of a quartercar model excited by the road surface profile [J]. Communications in Nonlinear Science and Numerical Simulation,2008,13(5):1373-1383.
[9] ZHU Q, ISHITOBI M. Chaos and bifurcations in a nonlinear vehicle model [J]. Journal of Sound and Vibration,2004,275(3/4/5):1136-1146.
[10] 李鸿光,何旭,孟光. BoucWen滞回系统动力学特性的仿真[J].研究系统仿真学报,2004,16(9): 2009-2011.
LI Hongguang, HE Xu, MENG Guang. Numerical simulation for dynamic characteristics of BoucWen hysteretic system [J]. Journal of System Simulation, 2004,16(9): 2009-2011.
[11] 周云,谭平.磁流变阻尼控制理论与技术[M].北京:科学出版社,2007:82-134.
[12]王维锐.车辆悬架系统关键技术研究[D]. 杭州:浙江大学,2007.
WANG Weirui. Study on some key technology of vehicle suspension system [D]. Hangzhou: Zhejiang University, 2007.

[1] 吴参, 王维锐, 陈颖, 等. 三维路面谱的仿真建模与验证[J]. J4, 2009, 43(10): 1935-1938.