Please wait a minute...
浙江大学学报(工学版)
生物医学工程、光学工程     
基于Van Der Pauw原理的溶液电导率计
余翔1, 张冰1, 林桢2, 张潇2, 魏佳莉1, 王晓萍1
1. 浙江大学 现代光学国家重点实验室,光电信息工程学系,浙江 杭州 310027;2. 浙江省计量科学研究院,浙江 杭州 310013
Electrolytic conductivity meter based on Van Der Pauw theory
YU Xiang1, ZHANG Bing1, LIN Zhen2, ZHANG Xiao2, WEI Jia-li1, WANG Xiao-ping1
1. State Key Laboratory of Modern Optical Instrumentation, Department of Optical Engineering and Information Science, Zhejiang University, Hangzhou 310027, China;2. Zhejiang Province Institute of Metrology, Hangzhou 310013, China
 全文: PDF(822 KB)   HTML
摘要:

为实现对于电导率的准确测量,研究Van Der Pauw原理及其应用于电导率绝对测量的理论依据,设计径轴二维可调的四电极结构.分析电极的对称性、电导池的封闭性对测量结果的影响,实验结果证明对称性好、结构封闭的Van Der Pauw法电导率计,对溶液电导率具有较高的测量精度,并能够实现绝对测量.基于Van Der Pauw法的电导池常数κ仅与电极长度有关的原则,设计几种不同电极长度的电极,开展多种不同电导率溶液的测量实验,得出不同电导池常数κ的最佳测量范围.运用电导池常数为0.1 cm-1的电极,对电导率为20~500 μS/cm内的多个实际水样进行测量,相对误差小于1.0%.结果表明该新型电导率测量方法具有很好的应用前景和推广价值.

Abstract:

In order to realize the accurate measurement for electrolytic conductivity of water, the principle of Van Der Pauw and its theoretical basis applied for absolute measurement electrolytic conductivity were studied, then the four-electrode with an axial-radial two-dimensional adjustment structure was designed. Through a series of experiments and analysis, the symmetrical electrodes and the closed conductivity cell can guarantee a high precision measurement result, and can also be achieved the absolute measurement. The conductance cell constant was only depended on the length of the electrode, several electrodes with different length, were designed, and the appropriate measurement range for each cell constant was also given. Finally, chose the electrode whose cell constant is 0.1 cm-1 to measure several actual samples with the conductivity range of 20~500 μS/cm, the relative errors are all less than 1.0%. The Van Der Pauw theory applied to the absolute measurement of the electrolytic conductivity, provides a well application prospect and popularization value.

出版日期: 2015-02-01
:  TH 89  
基金资助:

浙江省质量技术监督局重大科技计划资助项目(20110105);国家“863”高技术研究发展计划资助项目(2014AA06A504);浙江省科技厅重大科技专项资助项目(2012C13010-1)

通讯作者: 王晓萍,女,教授     E-mail: xpwang@zju.edu.cn
作者简介: 余翔(1989—),男,研究生,从事电化学传感器的研究工作.E-mail:yuxiang_zju@163.com
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

余翔, 张冰, 林桢, 张潇, 魏佳莉, 王晓萍. 基于Van Der Pauw原理的溶液电导率计[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2015.02.026.

YU Xiang, ZHANG Bing, LIN Zhen, ZHANG Xiao, WEI Jia-li, WANG Xiao-ping. Electrolytic conductivity meter based on Van Der Pauw theory. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2015.02.026.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2015.02.026        http://www.zjujournals.com/eng/CN/Y2015/V49/I2/371

[1] BHATIA R, DILLEEN J W, ATKINSON A L, et al. Combined physico-chemical and biological sensing in environmental monitoring[J]. Biosensors and Bioelectronics, 2003, 18(5): 667674.[2] MCCLESKEY R B, NORDSTROM D K, RYAN J N, et al. A new method of calculating electrical conductivity with applications to natural waters[J]. Geochimica et Cosmochimica Acta, 2012, 77: 369-382.
[3] GRYSINSKI T, MORON Z. Planar sensors for local conductivity measurements in biological objects—Design, modelling, sensitivity maps [J]. Sensors and Actuators B-Chemical, 2011, 158(1): 190-198.
[4] 周明军,尤佳,秦浩.电导率传感器发展概况[J].传感器与微系统,2010.29(4): 9-11.
ZHOU Ming-jun, YOU Jia, QIN Hao, et al. Overview on the development of conductivity sensor [J], Transducer and Microsystem Technologies, 2010, 29(4): 9-11.
[5] WU Y C, KOCH W F, PRATT K W. Proposed new electrolytic conductivity primary standards for kcl solutions [J]. Journal of Research of the National Institute of Standards and Technology, 1991, 96: 191-201.
[6] BRINKMANN F, DAM N E, DEAK E, DURBIANO F, et al. Primary methods for the measurement of electrolytic conductivity[J]. Accreditation and Quality Assurance, 2003, 8(7/8): 346-353.
[7] ORRU E, DURBIANO F, ORTOLANO M. Reference measurement system for low electrolytic conductivity values with a flowing solution [J]. Measurement Science and Technology, 2013, 24 0359033.
[8] VAN DER PAUW L J. A method of measuring specic resistivity and Hall effect of discs of arbitrary shape [J]. Philips Research Reports, 1958, 13: 19.
[9] MORON Z, RUCKI Z, SZCZEPANIK Z. The possibility of employing a calculable four-electrode conductance cell to substitute for the secondary standards of electrolytic conductivity [J]. IEEE Transactions on Instrumentation and Measurement, 1997, 46(6): 1268-1273.
[10] 魏佳莉. 基于Van Der Pauw 法的水溶液电导率绝对测量系统研究[D]. 杭州, 浙江大学, 2013.
WEI Jia-li.The research of measuring system of electrical conductivity of aqueous solution based on Van Der Pauw theory [D]. Hangzhou: Zhejiang University, 2013.
[11] RIETVELD G, KOIJMANS C V, HENDERSON L C A, et al. DC conductivity measurements in the Van Der Pauw geometry[J]. IEEE Instrumentation and Measurement Society, 2003, 52(2): 449-453.
[12] GB/T 27503-2011.电导率仪的试验溶液—氯化钠溶液制备方法. [S]. 北京: 国家机械工业局, 1999.
GB/T 27503-2011. Test solutions of electrolytic condcutivity analyzer—Preparation method of sodium chloride solutions. [S]. Beijing: State Bureau of Machine-Building Industry, 1999.

[1] 杨朝晖, 张进华, 洪军, 姚建国, 王煜. 超高精度滚动轴承旋转精度测试系统误差分析[J]. 浙江大学学报(工学版), 2014, 48(6): 1095-1101.
[2] 杨朝晖, 张进华, 洪军, 姚建国, 王煜. 超高精度滚动轴承旋转精度测试系统误差分析[J]. J4, 2014, 48(1): 0-00.