Please wait a minute...
浙江大学学报(工学版)
能源工程     
多物理场耦合激励下的高铁车内中频噪声计算
毛杰1, 郝志勇1, 孙强2, 郑旭1, 马晓龙2, 张强1
1. 浙江大学 能源工程学系,浙江 杭州 310027;2. 长春轨道客车股份有限公司,吉林 长春 130000
High-speed train medium-frequency interior noise calculation under multi-physical-field coupling excitations
MAO Jie1, HAO Zhi-yong1, SUN Qiang2, ZHENG Xu1, MA Xiao-long2, ZHANG Qiang1
1. Department of Energy Engineering, Zhejiang University, Hangzhou 310027, China;2. Changchun Railway Vehicles Co., Ltd, Changchun 130000, China
 全文: PDF(2272 KB)   HTML
摘要:

采用混合有限元-统计能量分析(FE-SEA)理论搭建某高速列车车厢的中频声学模型,考虑内饰件的声学性能,研究整备车厢的车内噪声.提出多物理场耦合激励下的高速列车车内结构辐射噪声计算方案,分别采用快速多极边界元、刚性多体动力学和大涡模拟结合Ffowcs Williams-Hawkings (FW-H)声类比法提取了350 km/h下的轮轨噪声、二系悬挂力和空气动力噪声,将这些激励源耦合后作用在列车混合模型上,计算200~1 600 Hz内的车内噪声.在相同车速下,选取车内中心距离地板1.2 m高度处的仿真与试验声压级进行对比,结果显示2条曲线的变化趋势基本一致,声压级总值相差2.7 dB,误差符合工程要求,验证了列车中频声学耦合模型及多物理场耦合激励的精度.

Abstract:

Hybrid finite element-statistical energy analysis (FE-SEA) theory was employed to construct the medium-frequency acoustic model of a high-speed railway train coach. Acoustic attributes of trim parts were taken into consideration to study the interior noise of a fully-trimmed coach. The calculation scheme for the high-speed train interior structural radiated noise under multi-physical-field coupled excitations was proposed, which adopted fast multi-pole boundary element analysis, rigid multi-body dynamics, and large-eddy simulation integrated with Ffowcs Williams-Hawkings (FW-H) acoustic analogy method to extract the wheel-rail noise, secondary suspension forces, and aerodynamic noise at 350 km/h. The excitations were coupled to stimulate the hybrid train model to calculate the interior noise in the frequency range of 200~1600 Hz. Finally, the simulated and measured sound pressure levels of an observation point which is 1.2 m above the interior center floor at the same speed were contrasted. The results indicate that the changing trends of two curves are generally consistent, and the deviation of the overall sound pressure level is 2.7 dB, which validates the accuracy of the hybrid model and coupled excitations in accordance with engineering permission.

出版日期: 2015-02-01
:  TB 532  
基金资助:

 国家科技部“十二五”863重大资助项目(2011AA11A103)

通讯作者: 郝志勇,男,教授,博导     E-mail: haozy@zju.edu.cn
作者简介: 毛杰(1987—),男,博士生,从事高速列车振动噪声控制研究.E-mail: maojie1987@zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

毛杰, 郝志勇, 孙强, 郑旭, 马晓龙, 张强. 多物理场耦合激励下的高铁车内中频噪声计算[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2015.02.018.

MAO Jie, HAO Zhi-yong, SUN Qiang, ZHENG Xu, MA Xiao-long, ZHANG Qiang. High-speed train medium-frequency interior noise calculation under multi-physical-field coupling excitations. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2015.02.018.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2015.02.018        http://www.zjujournals.com/eng/CN/Y2015/V49/I2/315

[1] 沈志云.高速列车的动态环境及其技术的根本特点[J].铁道学报, 2006, 28(4): 15.
SHEN Zhi-yun. Dynamic environment of high-speed train and its distinguished technology [J]. Journal of the China Railway Society, 2006, 28(4): 15.
[2] MAO J, HAO Z Y, JING G X, et al. Sound quality improvement for a four-cylinder diesel engine by the block structure optimization [J]. Applied Acoustics, 2013, 74(1): 150-159.
[3] FORSSEN J, TOBER S, CORAKCI A C, et al. Modelling the interior sound field of a railway vehicle using statistical energy analysis [J]. Applied Acoustics, 2012, 73(4): 307-311.
[4] SHORTER P J, GARDNER B K, BREMNER P G. A hybrid method for full spectrum noise and vibration prediction [J]. Journal of Computational Acoustics, 2003, 11(2): 323-338.
[5] 肖友刚, 康志成.高速列车乘客室内轮轨激励噪声的贡献度分析[J].华南理工大学学报:自然科学版, 2009, 37(2): 98101+106.
XIAO You-gang, KANG Zhi-cheng. Acoustic contribution analysis of passenger room of high-speed train under wheel-rail excitation [J]. Journal of South China University of Technology :Natural Science Edition, 2009, 37(2): 98101+106.
[6] 刘加利,张继业,张卫华.高速列车车内中高频气动噪声计算方法[J].交通运输工程学报,2011, 11(3): 55-60.
LIU Jia-li, ZHANG Ji-ye, ZHANG Wei-hua. Calculation method of interior aerodynamic noises with middle and high frequencies for high-speed train [J]. Journal of Traffic and Transportation Engineering, 2011, 11(3): 55-60.
[7] SAPENA J, TABBAL A, JOVE J, et al. Interior noise prediction in high-speed rolling stock driver’s cab: Focus on structure-borne paths (mechanical and aero sources) [J]. Noise and Vibration Mitigation for Rail Transportation Systems, 2012, 118: 445-452.
[8] COTONI V, SHORTER P, LANGLEY R. Numerical and experimental validation of a hybrid finite element-statistical energy analysis method [J]. Journal of the Acoustical Society of America, 2007, 122(1): 259-270.
[9] WANG X H, LU C J, ZHOU F L, et al. Acoustic problems analysis of 3D solid with small holes by fast multipole boundary face method [J]. Engineering Analysis with Boundary Elements, 2013, 37(12): 1703-1711.
[10] WU H J, LIU Y J, JIANG W K. A low-frequency fast multipole boundary element method based on analytical integration of the hypersingular integral for 3D acoustic problems [J]. Engineering Analysis with Boundary Elements, 2013, 37(2): 309-318.
[11] ZHANG N, SHEN H C, YAO H Z. Numerical simulation of cavity flow induced noise by LES and FW-H acoustic analogy [J]. Journal of Hydrodynamics, 2010, 22(5): 242-247.
[12] 房建英,肖新标,金学松,等.行车速度对高速列车车轮振动声辐射特性的影响[J].机械工程学报, 2010, 46(22): 96-104.
FANG Jian-ying, XIAO Xin-biao, JIN Xue-song, et al. Effect of train speed on acoustic radiation characteristics of high-speed train wheel vibration [J]. Journal of Mechanical Engineering, 2010, 46 (22): 96-104.
[13] 方锐,肖新标,房建英,等.轨道结构参数对其声辐射特性影响[J].铁道学报, 2011, 33(5): 78-84.
FANG Rui, XIAO Xin-biao, FANG Jian-ying, et al. Influence of track structure parameters on acoustic radiation [J]. Journal of the China Railway Society, 2011, 33(5): 78-84.
[14] 刘全刚.高速磁浮车的车内噪声控制计算研究[D].上海: 上海交通大学, 2008.
LIU Quan-gang. Research on interior noise control of high-speed maglev train [D]. Shanghai: Shanghai Jiaotong University, 2008.
[15] 马大猷.噪声与振动控制手册[M].北京:机械工业出版社, 2002.

[1] 罗乐,郑旭,吕义,郝志勇. 考虑受电弓系统的高速列车气动噪声分析[J]. 浙江大学学报(工学版), 2015, 49(11): 2179-2185.
[2] 毛杰, 郝志勇, 卢兆刚, 陈馨蕊. 基于FE-SEA混合法的
汽车镁合金前围板隔声量数值计算
[J]. J4, 2012, 46(12): 2184-2188.
[3] 李冰茹, 王宣银, 葛辉良. 圆柱壳体近场辐射噪声预报与实验研究[J]. J4, 2010, 44(3): 563-568.
[4] 徐亮, 陈心昭, 毕传兴, 等. 近场声全息分辨率增强的正交球面波插值方法[J]. J4, 2009, 43(10): 1808-1811.