木质素高温炭化制备导电焦炭特性研究

doi:10.3785/j.issn.1008-973X.2014.10.006

浙江大学学报(工学版)

能源与机械工程

木质素高温炭化制备导电焦炭特性研究

吴荣兵, 肖刚, 陈冬, 周慧龙, 倪明江, 高翔, 岑可法

浙江大学能源清洁利用国家重点实验室,浙江杭州 310027

Characteristics of electrically conductive charcoal prepared by high temperature carbonization of lignin

WU Rong-bing, XIAO Gang, CHEN Dong, ZHOU Hui-long, NI Ming-jiang, GAO Xiang, CEN Ke-fa

State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China

全文: PDF(2073 KB) HTML

摘要：

以木质素为原料,对高温炭化制备的焦炭进行酸洗,得到导电性及孔隙结构良好的焦炭,研究炭化温度对焦炭特性的影响.通过X射线衍射（XRD）、扫描电镜（SEM）、傅里叶红外光谱（FTIR）以及N2吸附仪(BET)对焦炭性能进行表征.实验结果表明,炭化温度在800 ℃以上时,木质素中的Na2CO3经高温分解成Na2O和CO2,析出的CO2可能会对焦炭孔隙起活化作用.随着炭化温度的升高,焦炭微孔的体积分数减小,中孔的体积分数增加,孔径主要集中在2～6 nm.炭化温度为1 200 ℃,酸洗后的焦炭电阻率可以降至0.076 Ω·cm.

Abstract:

Charcoal with good electric conductivity and developed pore structure was prepared by high temperature carbonization followed by HCl treatment using lignin as raw material. The properties of charcoal from different carbonization temperature were characterized by X-ray diffraction (XRD), scanning electron microscopy (SEM), Fourier infrared spectrum (FTIR) and Brunauer-Emmett-Teller (BET) method. Experimental results indicated that charcoal activation took place through gasfication of CO2 produced from Na2CO3 during carbonization at over 800 ℃. Mesopore volume fraction increased and micropore volume fraction decreased with the increase of carbonization temperature, and the pore size mainly ranged from 2 nm to 6 nm. The electrical resistivity of charcoal could reduce to 0.076 Ω·cm at 1 200 ℃.

出版日期: 2014-10-01

TK 6

基金资助:

国家自然科学基金资助项目(51276167);浙江省自然科学基金资助项目（LY12E06005）.

通讯作者: 肖刚，男，副教授 E-mail: xiaogangtianmen@zju.edu.cn

作者简介: 吴荣兵(1989—),男，硕士生，从事生物质气化焦油吸附降解的研究.E-mail: wrbceu@zju.edu.cn

	服务
	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

引用本文:

吴荣兵, 肖刚, 陈冬, 周慧龙, 倪明江, 高翔, 岑可法. 木质素高温炭化制备导电焦炭特性研究[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2014.10.006.

WU Rong-bing, XIAO Gang, CHEN Dong, ZHOU Hui-long, NI Ming-jiang, GAO Xiang, CEN Ke-fa.

Characteristics of electrically conductive charcoal prepared by high temperature carbonization of lignin

. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2014.10.006.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2014.10.006 或 http://www.zjujournals.com/eng/CN/Y2014/V48/I10/1752

［1］卢平,陆飞,树童,等.生物质热解焦吸附模拟烟气中的SO2和NO的实验研究［J］.中国电机工程学报,2012, 32(35): 37-45.

LU Ping, LU Fei, SHU Tong, et al. Experimental study on adsorption characteristics of SO2 and NO using biomass-pyrolysis chars ［J］. Proceedings of the CSEE, 2012, 32(35): 37-45.

［2］陈建宇,刘资文,李平,等.改性蜂窝状活性炭吸附二氧化碳和氮气的热力学［J］.化工学报,2012, 63(10): 3017-3026.

CHEN Jian-yu, LIU Zi-wen, LI Ping, et al. Thermodynamic study of CO2 and N2 adsorption on modified activated carbon monolith ［J］. Journal of Chemical Industry and Engineering, 2012, 63(10): 3017-3026.

［3］杨娟,汪印,余剑,等.活性炭负载金属氧化物常温脱除低浓度NO［J］.化工学报,2012, 63(8): 2358-2543.

YANG Juan, WANG Yin, YU Jian, et al. Removal of low concentration NO at room temperature using metal oxide supported on activated carbon ［J］. Journal of Chemical Industry and Engineering, 2012, 63(8): 2358-2543.

［4］张敏敏,田艳红,张学军,等.酚醛树脂基活性炭材料的制备及其电化学性能［J］.化工学报,2012, 63(7): 2310-2316.

ZHANG Min-min, TIAN Yan-hong, ZHANG Xue-jun, et al. Preparation and electrochemical properties of PF-based activated carbon ［J］. Journal of Chemical Industry and Engineering, 2012, 63(7): 2310-2316.

［5］ XIAO Gang, NI Ming-jiang, XIAO Rui, et al. Catalytic carbonization of lignin for production of electrically conductive charcoal ［J］. Journal of Biobased Materials and Bioenergy, 2012, 6(1): 69-74.

［6］谭洪,王树荣,骆仲泱,等.木质素快速热解试验研究［J］.浙江大学学报：工学版,2005, 39(5): 710-714.

TAN Hong, WANG Shu-rong, LUO Zhong-yang, et al. The study of lignin pyrolysis experiment ［J］. Journal of Zhejiang University: Engineering Science, 2005, 39(5): 710-714.

［7］ CAO Jun, XIAO Gang, XU Xiao, et al. Study on carbonization of lignin by TG-FTIR and high-temperature carbonization reactor ［J］. Fuel Processing Technology, 2013, 106(1): 41-47.

［8］王正芳,郑正,罗兴章,等.互花米草厌氧发酵渣活性炭的制备及吸附性能研究［J］.农业环境科学学报,2010, 29(7): 1374-1381.

WANG Zheng-fang, ZHENG Zheng, LUO Xing-zhang, et al. Preparation,characterization and absorption capability of activated carbon from anaerobic digested residue of salterniflora ［J］. Journal of Agro-Environment Science, 2010, 29(7): 1374-1381.

［9］张华,彭勤纪,李亚明,等.现代有机波谱分析［M］.北京:化学工业出版社,2005.

［10］曹俊,肖刚,许啸,等.木质素热解/炭化官能团演变与焦炭形成［J］.东南大学学报：自然科学版,2012, 42(1): 83-87.

CAO Jun, XIAO Gang, XU Xiao, et al. Functional groups evolvement and charcoal formation during lignin pyrolysis/carbonization ［J］. Journal of Southeast University: Natural Science Edition, 2012, 42(1): 83-87.

［11］ NAKAGAWA Y, MOLINA-SABIO M, RODRIGUEZ-REINOSO F. Modification of the porous structure along the preparation of activation carbon monoliths with H3PO4 and ZnCl2 ［J］. Microporous and Mesoporous Materials, 2007, 103(1/2/3): 29-34.

［12］张文标,华毓坤,叶良明.竹炭导电机理的研究［J］.南京林业大学:自然科学版, 2002, 26(4): 47-50.

ZHANG Wen-biao, HUA Yu-kun, YE Liang-ming. A study on mechanism of electric conduction of bamboo charcoal ［J］. Journal of Nanjing Forestry University: Natural Sciences Edition, 2002, 26(4): 47-50.

［13］江泽慧,张东升,费本华,等.炭化温度对竹炭微观结构及电性能的影响［J］.新型炭材料,2004, 19(4): 250-253.

JIANG Ze-hui, ZHANG Dong-sheng, FEI Ben-hua, et al. Carbonization temperature on the microstructure and electric properties of bamboo charcoal ［J］. New Carbon Materials, 2004, 19(4): 250-253.

［14］肖刚,刘继驰,金保昇,等.稻壳类秸秆高温炭化焦炭的特性研究［J］.燃烧科学与技术,2010, 29(6): 1220-1225.

XIAO Gang, LIU Ji-chi, JIN Bao-sheng, et al. Characteristics of rice straw and hull charcoal by high-temperature carbonization ［J］. Journal of Combustion Science and Technology, 2010, 29(6): 1220-1225.

[1]	刘长奇, 黄亚继, 王昕晔, 卢志海, 刘凌沁. 玉米秸秆制精制油的生命周期温室气体排放研究[J]. 浙江大学学报(工学版), 2016, 50(10): 1871-1878.
[2]	龚彬, 余春江, 王准, 骆仲泱. 生物质炉排锅炉不同受热面沉积特性[J]. 浙江大学学报(工学版), 2015, 49(8): 1578-1584.
[3]	陈超, 周劲松, 项阳阳, 顾珊, 骆仲泱. 生物质高温气流床分级气化特性[J]. 浙江大学学报(工学版), 2015, 49(4): 626-631.
[4]	吴何来,周劲松,许沧粟,陈文,杨义,骆仲泱. 超临界乙醇提质生物油的汽油机试验研究[J]. 浙江大学学报(工学版), 2015, 49(1): 136-141.
[5]	周慧龙,肖刚,吴荣兵,黄磊,倪明江,高翔,岑可法. 炭化温度对木质素导电炭石墨化结构的影响[J]. 浙江大学学报(工学版), 2014, 48(11): 2066-2071.
[6]	余春江,王准,龚彬,骆仲泱. 生物质锅炉钢材在氯化钾接触条件下腐蚀特性[J]. 浙江大学学报(工学版), 2014, 48(11): 2046-2052.
[7]	伏启让,黄亚继,牛淼淼,杨高强,刘长奇, 王昕晔. 垃圾衍生燃料流化床富氧气化实验研究[J]. 浙江大学学报(工学版), 2014, 48(7): 1265-1271.
[8]	陈冠益,孔韡,徐莹,李婉晴,马隆龙,颜蓓蓓,陈鸿. 生物质化学制氢技术研究进展[J]. 浙江大学学报(工学版), 2014, 48(7): 1318-1328.
[9]	程军,庄良,黄云, 孙晶,周俊虎,岑可法. 平板式微藻光反应器的流场优化及闪光效应[J]. J4, 2013, 47(11): 1958-1963.
[10]	朱颖颖, 王树荣, 葛晓岚, 李信宝, 周劲松, 骆仲泱. 生物质基合成气合成甲醇的热力学模拟研究[J]. J4, 2011, 45(2): 341-347.
[11]	陈玲红, 吴法, 王勇,吴学成,周昊,岑可法. 基于时域激光诱导辐射确定湍流火焰烟黑粒径[J]. J4, 2010, 44(11): 2169-2172.
[12]	马孝琴, 秦建光, 骆仲泱, 余春江, 方梦祥, 岑可法. 添加剂对稻草灰熔融特性影响的实验研究[J]. J4, 2010, 44(8): 1573-1578.
[13]	陈玲红, 吴学成, 周昊, 岑可法. 热重红外联用多组分混合气体产物定量分析[J]. J4, 2010, 44(8): 1579-1583.
[14]	王琦, 骆仲泱, 王树荣, 岑可法. 生物质快速热裂解制取高品位液体燃料[J]. J4, 2010, 44(5): 988-990.
[15]	宋文路, 程军, 谢斌飞, 周俊虎, 岑可法. 脂肪预处理发酵联产氢气和甲烷的研究[J]. J4, 2010, 44(3): 476-481.

Viewed

Full text

Abstract

Cited

Shared

Discussed