Please wait a minute...
J4  2011, Vol. 45 Issue (1): 191-196    DOI: 10.3785/j.issn.1008-973X.2011.01.033
化学工程     
新型抗真菌抗生素分离与纯化
王学万1,陈华1,2,陈正杰2,吴绵斌1
1.浙江大学 化学工程与生物工程学系, 浙江 杭州 310027; 2.浙江省抗真菌药物研究重点实验室, 浙江 台州 318000
Isolation and purification of novel antifungal antibiotic from
streptomyces ahygroscopicus
WANG Xue-wan1, CHEN Hua1, 2, CHEN Zheng-jie2, WU Mian-bin1
1.Department of Chemical Engineering and Bioengineering, Zhejiang University, Hangzhou 310027, China;
2.Zhejiang Key Laboratory of Antifungal Drugs, Taizhou 318000, China
 全文: PDF  HTML
摘要:

对1株不吸水链霉菌(Streptomyces ahygroscopicus ZJUIB001)产生的新型抗真菌抗生素进行分离纯化研究.通过发酵液经离心去沉淀后,采用氯仿和石油醚萃取.萃取后的水相调节至pH=2并采用Dowex 50 × 16阳离子交换树脂和XAD7HP大孔吸附树脂分离其中的抗真菌代谢物,对分离样品进行反相高效液相色谱分析.Dowex 50×16层析条件优化如下:pH=2的萃取浓缩液以2倍床层体积/h的流速上柱,在去离子水冲洗后,用0.6 mol/L氨水以1倍床层体积/h流速洗脱;Amberlite XAD7HP大孔吸附树脂层析条件为:体积分数为10%和70%的乙醇水溶液阶跃洗脱.将纯化得到的样品用高效液相色谱(HPLC)系统检测,色谱柱为YMC-C18 (5 μm, Φ4.6 mm × 250 mm)氰基柱,流动相为0.01 mol/L的乙酸铵缓冲液(pH=4.3),流速为1 mL/min,检测波长为220 nm. HPLC检测结果显示,分离的抗生素纯度和效价分别达到93.0%和21 632 U/mg.

Abstract:

A technically feasible purification process for a novel pyrimidine nucleoside antifungal antibiotic produced by a Streptomyces strain (Streptomyces ahygroscopicus ZJUIB001) was conducted. The centrifugated culture broth was extracted with chloroform and then with petroleum ether. The water phase solution was adjusted to pH=2 and further isolated by cation-exchange chromatography, which was followed by macroporous resin adsorption. Dowex 50 × 16 was screened as the most suitable cation-exchange resin for removing the impurity from the crude extract under the optimized operating conditions as follows: sample loading flow rate of 2 bed volume (BV) per hour and eluting flow rate of 1 BV per hour using 0.6 mol/L NH3·H2O as the mobile phase. Amberlite XAD7HP was selected as the most suitable macroporous adsorption resin for the further purification of the antibiotic. The optimized desorbing condition of macroporous resin adsorption chromatography was multi-step gradient elution with ethanol solutions of 10% and 70% volume fraction, respectively. Then the purified antifungal compound was subjected to high-performance liquid chromatographu (HPLC) system with a YMC-C18 (5 μm, Φ4.6 mm×250 mm) column. The mobile phase was 0.01 mol/L ammonium acetate buffer (pH 4.3). The flow rate was 1 mL/min and the elution was detected at 220 nm. HPLC results show that the purified antibiotic compound has a purity of 93.0% with antifungal activity of 21 632 U/mg.

出版日期: 2011-03-03
:  Q 814.2  
基金资助:

浙江省科技厅计划资助项目(2009C33019) ; 台州市—浙江大学科技合作专项资金资助项目(08ZJU007).

通讯作者: 吴绵斌,男,副教授.     E-mail: wumb@zju.edu.cn
作者简介: 王学万(1986-),男,山东日照人,硕士生,从事生物化工研究.E-mail: wangxwzju@gmail.com
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

王学万,陈华,陈正杰,吴绵斌. 新型抗真菌抗生素分离与纯化[J]. J4, 2011, 45(1): 191-196.

WANG Xue-wan, CHEN Hua, CHEN Zheng-jie, WU Mian-bin. Isolation and purification of novel antifungal antibiotic from
streptomyces ahygroscopicus. J4, 2011, 45(1): 191-196.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2011.01.033        http://www.zjujournals.com/eng/CN/Y2011/V45/I1/191

[1] BIGLIARDI E, BERNUZZI A M, CORONA S, et al. In vitro efficacy of nikkomycin Z against the human isolate of the microsporidian species Encephalitozoon hellem[J]. Antimicrobial Agents and Chemotherap, 2000, 44(11): 3012-3016.
[2] ANDERSON M B, ROEMER T, FABREY R. Progress in antifungal drug discovery [J]. Annual Reports in Medicinal Chemistry, 2003, 38: 163-172.
[3] CHILLER T, FARROKHSHAD K, BRUMMER E, et al. The interaction of human monocytes, monocytederived macrophages, and polymorphonuclear neutrophils with caspofungin (MK0991), an echinocandin, for antifungal activity against Aspergillus fumigatus[J]. Diagnostic Microbiology and Infectious Disease, 2001, 39(2): 99-103.
[4] DONDAS H A, FISHWICK C, GRIGG R, at al. 1, 3dipolar cycloaddition of stabilised and nonstabilised azomethine ylides derived from uracil polyoxin C (UPoC): access to nikkomycin analogues [J]. Tetrahedron, 2004, 60(15): 3473-3485.
[5] 娄丹. 一种新型抗真菌抗生素的发酵与分离 [D]. 杭州: 浙江大学, 2006.
LOU Dan. Study on fermentation, isolation and characterization of a novel antifungalantibiotic [D]. Hangzhou: Zhejiang University, 2006.
[6] 张国松. 新型抗真菌抗生素的发酵生产及分离工艺的研究 [D]. 杭州: 浙江大学, 2008.
ZHANG Guosong. Studies on fermentation, isolation and characterization of a novel antifungalantibiotic [D]. Hangzhou: Zhejiang University, 2008.
[7] SALGADO H, LOPES C, LUCCHESI M. Microbiological assay for gatifloxacin in pharmaceutical formulations [J]. Journal of Pharmaceutical and Biomedical Analysis, 2006, 40(2): 443-446.
[8] BRUCKNER R C, ZHAO G H, VENCI D, et al. Nikkomycin biosynthesis: formation of a 4electron oxidation product during turnover of NikD with its physiological substrate [J]. Biochemistry, 2004, 43 (28): 9160-9167.
[9] GUPTE M D, KULKARNI P R. A study of antifungal antibiotic production by Streptomyces chattanoogensis MTCC 3423 using full factorial design [J]. Letters in Applied Microbiology, 2002, 35(1): 22-26.
[10] 张荣升, 严希康,朱留沙,等.亚微米强酸树脂对庆大霉素的吸附特性研究[J].中国医药工业杂志, 1999,30(6): 248-250.
ZHANG Rongsheng, YAN Xikang, ZHU Liusha, et al. Study of adsorption of gentamicinon submicrosized strongacidic resin [J]. Chinese Journal of Pharmaceuticals, 1999, 30(6): 248-250.
[11] BENNETT J V, BRODIE J L, BENNER E J, et al. Simplified accurate method for antibiotic assay of clinical specimens [J]. Applied Microbiology, 1966, 14: 170-177.             

[1] 陈正杰, 朱婉萍, 张书衍, 吴绵斌, 贺娟, 陈华, 孟强. 新型抗真菌代谢产物发酵条件的响应面优化[J]. J4, 2011, 45(10): 1868-1876.