Please wait a minute...
浙江大学学报(工学版)
J4  2010, Vol. 44 Issue (12): 2342-2347    DOI: 10.3785/j.issn.1008-973X.2010.12.018
土木工程     
基于三维有限元分析的压电阻抗模型及其应用
蔡金标1, 陈勇1, 严蔚2
1.浙江大学 建筑工程学院,浙江 杭州310058； 2.宁波大学 建筑工程与环境学院,浙江 宁波315211
Three-dimensional finite element analysis based electromechanical
impedance model and its application
CAI Jin-biao1, CHEN Yong1, YAN Wei2
1. College of Civil Engineering and Architecture, Zhejiang University, Hangzhou 310058, China; 2. Faculty of
Architectural, Civil Engineering and Environment, Ningbo University, Ningbo 315211, China
 全文: PDF  HTML
摘要：

为了校核高频电阻抗分析的现有结构理论和验证，基于高频电阻抗信号的结构损伤监测方法的有效性，提出可应用结构健康监测的精确压电阻抗有限元模型.考虑压电片-黏结层-主体结构三者的耦合作用和黏结层的影响，通过三维有限元谐响应分析方法，利用通用有限元软件ANSYS，建立由压电片-黏结层-主体结构组成的耦合系统的三维有限元模型，并进行了数值模拟和相应的实际模型试验.计算及研究结果表明：采用三维精细压电有限元模型，可精确地预测到电导纳谱中的共振模态，得到的结果与实验结果吻合，且能有效地校核高频电阻抗分析的现有结构理论；采用压电阻抗法能够很好地识别结构局部的细小损伤，通过合理布置压电片可以识别结构损伤的位置.
Abstract:

An accurate electromechanical impedance(EMI) finite element model was established for structural health monitoring, in order to check the existing structure theories for highfrequency impedance analysis and to verify the effectiveness of the damage detection method based on highfrequency electric impedance signals. The coupling interaction among piezoelectric patches, adhesive layer, and main structure was considered and the effect of adhesive layers on EMI signals was further taken into account. A threedimensional finite element model was developed to simulate this coupled structural system using the software ANSYS and the correlative experimental study was conducted. Results showed that the harmonic analysis based on the threedimensional finite element model could predict the vibration modes of the structure at high frequency, which agreed well with the experimental results, and the existing structure theories for highfrequency impedance analysis were effectively checked. Further study also showed that the EMI technique can feasibly detect small and local damages in structures. In addition, the location of structural damage can be determined through reasonable distribution of piezoelectric-ceramic patches.
出版日期: 2010-12-01
:  TU 323  
基金资助:

国家自然科学基金资助项目（50778161）；浙江省自然科学基金资助项目（Y107796）；宁波市自然科学基金资助项目（2008A610101）.
作者简介: 蔡金标（1965—），男，浙江浦江人，副教授，主要从事结构有限元分析和结构损伤监测方面研究.E-mail: caijb@zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

蔡金标, 陈勇, 严蔚. 基于三维有限元分析的压电阻抗模型及其应用[J]. J4, 2010, 44(12): 2342-2347.

CAI Jin-biao, CHEN Yong, YAN Wei. Three-dimensional finite element analysis based electromechanical
impedance model and its application. J4, 2010, 44(12): 2342-2347.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2010.12.018    或    http://www.zjujournals.com/eng/CN/Y2010/V44/I12/2342

［1］ LIANG C, SUN F P, ROGERS C A. An impedance method for dynamic analysis of active material systems ［J］. Journal of Vibration and Acoustics, 1994, 116(1): 120-128.
［2］ SUN F P, CHAUDHRY Z, LIANG C, et al. Truss structure integrity identification using PZT sensoractuator ［J］. Journal of Intelligent Material Systems and Structures, 1995, 6(1): 134-139.
［3］ XU Y G, LIU G R. A modified electromechanical impedance model of piezoelectric actuatorsensor for debonding detection of composite patches ［J］. Journal of Intelligent Material Systems and Structures, 2002, 13(4): 389-396.
［4］ BHALLA S, SOH C K. Structural health monitoring by piezoimpedance transducer： I. modeling ［J］. Journal of Aerospace Engineering, 2004, 17(4): 154-165.
［5］ BHALLA S, SOH C K. Electromechanical impedance modeling for adhesively bonded piezotransducer ［J］. Journal of Material Systems and Structures, 2004, 15(12): 955-972.
［6］ MAKKONEN T, HOLAPPA A, ELLA J, et al. Finite element simulations of thinfilm composite BAW resonators IEEE Trans ［J］. IEEE Transaction. Ultrasonics Ferroelectrics Frequency Control, 2001, 48(12):41-58.
［7］ YANG Y W, LIM Y Y, SOH C K. Practical issues related to the application of the electromechanical impedance technique in the structural health monitoring of civil structures:Ⅱ.Numerical verification ［J］. Smart Materials and Structures, 2008, 35(6): 9-21.
［8］ NAIDU A S K, SOH C K. Damage severity and propagation characterization with admittance signatures of piezo transducers ［J］. Smart Materials and Structures, 2004, 13(2): 393-403.
［9］ YAN W, LIM C W, CHEN W Q, et al. Application of EMI technique for crack detection in continuous beams adhesively bonded with multiple piezoelectric patches ［J］. Mechanics of Advanced Materials and Structures, 2008, 15(1): 1-11.
［10］ LEE U, SHIN J. A frequencydomain method of structural damage identification formulated from the dynamic stiffness equation of motion ［J］. Journal of Sound and Vibration, 2002, 257(4): 615-634.
[1] 郭佳民, 董石麟, 袁行飞, 等. 索穹顶结构施工模拟分析[J]. J4, 2009, 43(10): 1892-1896.