Please wait a minute...
浙江大学学报(工学版)
浙江大学学报(工学版)  2017, Vol. 51 Issue (9): 1851-1860    DOI: 10.3785/j.issn.1008-973X.2017.09.020
电气工程     
永磁起动/发电机系统的参数匹配标定与实现
杜锦华1,2, 薛运田1, 刘全威1
1. 西安交通大学 电力设备电气绝缘国家重点实验室, 陕西 西安 710049;
2. 中航工业庆安集团有限公司, 陕西 西安 710077
Parameter matching calibration and implementation of permanent magnet integrated starter/generator system
DU Jin-hua1,2, XUE Yun-tian1, LIU Quan-wei1
1. State Key Laboratory of Electrical Insulation and Power Equipment, Xi'an Jiaotong University, Xi'an 710049, China;
2. Aviation Industry Corporation of Qing'an Group Co., Xi'an 710077, China
 全文: PDF(3360 KB)   HTML
摘要：

为了实现燃油经济指标最优，结合系统的设计需求和典型工况下的控制策略，对混合动力汽车（HEVs）用永磁起动/发电机（ISG）系统进行参数匹配标定.系统参数的匹配标定考虑了电动和发电工况下不同控制策略约束条件对起动/发电机（ISG）外特性的要求，以及最大功率点和最大转矩点对逆变器参数选型的影响；根据动力性匹配的峰值参数，确定高效区系统性能参数的取值范围.基于系统外特性参数匹配，分析凸极比和弱磁系数对电磁参数的影响规律，对电机的结构参数进行匹配标定，得到起动/发电机和逆变器的优化匹配设计方案.仿真和实验分析结果表明：经过参数匹配标定的样机系统能同时满足起动过程的外特性要求和发电过程的性能指标要求.
Abstract:

Parameter matching design of permanent magnet integrated starter/generator (ISG) system used in hybrid electric vehicles (HEVs) was studied in consideration of system design requirements and control strategies under typical operating conditions in order to obtain high fuel economy performance. The system parameter matching design considered the requirements for ISG external characteristics under different control strategies' constrains for generating and motoring modes. Moreover, the effect of maximum power and torque on converter parameters were also considered. According to the parameters matching with peak values of dynamic characteristics, the range of performance parameters in high efficiency area was obtained. Based on the parameters matching with external characteristics, the influences of saliency ratio and flux weakening ratio on electromagnetic parameters were analyzed, and the optimal matching design of ISG and converter was achieved. Furthermore, the analysis of simulations and experiments results show that the prototype system, which is obtained from parameter matching design method, can meet not only the requirement of external characteristics under starting conditions but also the performance requirements under generating conditions.
收稿日期: 2016-09-14 出版日期: 2017-08-25
CLC:  TM351  
基金资助:

国家自然科学基金资助项目（51407137）；高等学校博士点专项科研基金（20130201120010）；中国博士后基金资助项目（150643）.
作者简介: 杜锦华,女,讲师,博士,从事电机设计及其驱动研究.orcid.org/0000-0002-1365-0980.E-mail:jinhuadu@mail.xjtu.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
作者相关文章　　

引用本文:

杜锦华, 薛运田, 刘全威. 永磁起动/发电机系统的参数匹配标定与实现[J]. 浙江大学学报(工学版), 2017, 51(9): 1851-1860.

DU Jin-hua, XUE Yun-tian, LIU Quan-wei. Parameter matching calibration and implementation of permanent magnet integrated starter/generator system. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 2017, 51(9): 1851-1860.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2017.09.020    或    http://www.zjujournals.com/eng/CN/Y2017/V51/I9/1851

[1] KAMIEV K, MONTONEN J, RAGAVENDRA M P. Design principles of permanent magnet synchronous machines for parallel hybrid or traction applications[J]. IEEE Transactions on Industrial Electronics, 2013,60(11):4881-4890.
[2] SEO J H, KIM S M, JUNG H K. Rotor-design strategy of IPMSM for 42 V integrated starter/generator[J]. IEEE Transactions on Magnetics,2010,46(6):2458-2461.
[3] 张岳,曹文平,MARROW J. 电动车用内置式永磁电机(PMSM)设计[J].电工技术学报,2015,30(14):108-115. ZHANG Yue, CAO Wen-ping, MARROW J. Design of an interior permanent magnet synchronous motor (PMSM) for EV traction[J]. Transactions of China Electrotechnical Society, 2015,30(14):108-115.
[4] 王晓远,高鹏,赵玉双.电动汽车用高功率密度电机关键技术[J].电工技术学报,2015,30(6):53-59. WANG Xiao-yuan, GAO Peng, ZHAO Yu-shuang. Key technology of high power density motors in electric vehicles[J]. Transactions of China Electrotechnical Society, 2015,30(6):53-59.
[5] 段建东,赵克,孙力,等.永磁同步发电机效率最优联合控制[J].电工技术学报,2012,27(3):49-55. DUAN Jian-dong, ZHAO Ke, SUN Li, et al. Optimal efficiency joint control for permanent magnet synchronous generators[J]. Transactions of China Electrotechnical Society, 2012,27(3):49-55.
[6] BONTHU S S R, BAEK J, ISLAM M Z, et al. Optimal design of five phase permanent magnet assisted synchronous reluctance motor for integrated starter/generator application[C]//2015 IEEE International Electric Machines and Drives Conference (IEMDC). Coeur d'Alene:IEEE,2015:433-439.
[7] LEGRABGER J, FRIEDRICH G, VIVIER S,et al.Combination of finite-element and analytical models in the optimal multi-domain design of machines:application to an interior permanent-magnet starter/generator[J].IEEE Transactions on Industry Applications,2010,46(1):232-239.
[8] GRIFFO A, WROBEL R, MELLOR P H, et al. Design and characterization of a three-phase brushless exciter for aircraft starter/generator[J]. IEEE Transactions on Industry Applications, 2013, 49(5):2106-2115.
[9] YEOH S S.Control design for PMM-based starter/generator system for more electric aircraft[C]//201416th European Conference on Power Electronics and Applications. Lappeenranta:IEEE,2014:1-10.
[10] GAO F, BOZHKO S, YEOH S S. Control design for PMM starter-generator operated in flux-weakening mode[C]//Power Engineering Conference (UPEC). Dublin:IEEE, 2013:1-6.
[11] 夏永洪,王善铭,黄劭刚,等.齿谐波励磁的混合励磁永磁同步发电机[J].清华大学学报:自然科学版,2011,51(11):1557-1561. XIA Yong-hong, WANG Shan-ming, HUANG Shao-gang, et al. Hybrid excitation permanent magnet synchronous generator utilizing tooth harmonics for the excitation[J]. Journal of Tsinghua University:Science and Technology, 2011,51(11):1557-1561.
[12] 彭兵,夏加宽,王成元,等.近极槽数表贴式永磁同步电机齿顶漏磁分析与计算[J].电工技术学报,2012,27(1):114-118. PENG Bin, XIA Jia-kuan, WANG Cheng-yuan, et al.Axial flux leakage of coordinate structure hybrid excitation synchronous machine and its influence[J]. Transactions of China Electrotechnical Society, 2012,27(1):114-118.
[13] 李艳明,郭宏,谢清明,等.微燃机用高速永磁同步起动发电机驱动控制策略研究[J].电气传动,2013,43(4):17-21. LI Yan-ming, GUO Hong, XIE Qing-ming, et al. Research on the drive and control strategy of the high speed permanent magnet synchronous starter/generator used in the microturbine generation system[J]. Electric Drive, 2013, 43(4):17-21.
[14] 唐朝晖,丁强,喻寿益, 等.内埋式永磁同步电机的弱磁控制策略[J].电机与控制学报,2010,14(5):68-72. TANG Zhao-hui, DING Qiang, YU Shou-yi, et al. Research of flux weakening strategy of interior permanent magnet synchronous motor[J]. Electric Machines and Control,2010,14(5):68-72.
[15] 卢东斌,欧阳明高,谷靖,等.电动汽车永磁同步电机最优制动能量回馈控制[J].中国电机工程学报,2013,33(3):83-91. LU Dong-bin, OU Yang-ming-gao, GU Jing, et al. Optimal regenerative braking control for permanent magnet synchronous motors in electric vehicles[J]. Proceedings of the Chinese Society for Electrical Engineering, 2013,33(3):83-91.
[16] 李政,胡广大,崔家瑞,等.永磁同步电机调速系统的积分型滑模变结构控制[J].中国电机工程学报,2014,34(3):431-437. LI Zheng, HU Guang-da, CUI Jia-rui, et al. Sliding-mode variable structure control with integral action for permanent magnet synchronous motor[J]. Proceedings of the Chinese Society for Electrical Engineering, 2014,34(3):431-437.
[17] KAMIEV K, MONTONEN J, RAGAVENDRA M P, et al. Design principles of permanent magnet synchronous machines for parallel hybrid or traction applications[J]. IEEE Transactions on Industrial Electronics, 2013, 60(11):4880-4890.
[18] 郑维.混合动力汽车动力总成参数匹配方法与控制策略的研究[D].哈尔滨:哈尔滨工业大学,2010:43-62. ZHENG Wei. Research on power train parameter matching method and control strategy for hybrid electric vehicle[D]. Harbin:Harbin Institute of Technology, 2010:43-62.
[19] 曹永霞.混合动力汽车用永磁同步电机参数匹配与控制算法研究[D].吉林:吉林大学,2015:21-42. CAO Yong-xia. Research on permanent magnet synchronous motor parameter matching and control algorithm for hybrid electric vehicle[D]. Jilin:Jilin University,2015:21-42.
[20] 任海英.双凸极起动/发电机系统一体化设计与实现[D].南京:南京航空航天大学,2006:13-17. REN Hai-ying. Integral design and implementation of doubly salient starter/generator[D]. Nanjing:Nanjing University of Aeronautics and Astronautics,2006:13-17.
[21] 罗德荣,张洪彬,蔡亚辉,等.起发一体机发电模式的弱磁电压控制策略[J].电网技术,2015,39(8):2291-2296. LUO De-rong, ZHANG Hong-bin, CAI Ya-hui, et al. Flux-weakening voltage control strategy of the integrated starter/generator motor in generator mode[J]. Power System Technology, 2015, 39(8):2291-2296.
[1] 王凯, 金孟加, 沈建新. 三次谐波法控制的高速无刷电机转子结构研究[J]. J4, 2010, 44(3): 557-562.