Please wait a minute...
浙江大学学报(工学版)
J4  2012, Vol. 46 Issue (12): 2189-2193    DOI: 10.3785/j.issn.1008-973X.2012.12.008
能源工程     
旋流燃烧器出口气固两相流场的
光学波动法测量研究
周昊, 吴剑波, 杨玉, 李亚鹏, 胡善涛, 岑可法
浙江大学 能源清洁利用国家重点实验室,浙江 杭州 310027
Experimental measurement of gas-solid two-phase flow of
a swirl burner by optical wave method
ZHOU Hao, WU Jian-bo, YANG Yv, LI Ya-peng, HU Shan-tao, CEN Ke-fa  
State Key Laboratory of Clean Energy Utilization Institute, Zhejiang University，Hangzhou 310027, China
 全文: PDF  HTML
摘要：

为了精确测量旋流燃烧器出口的固相质量分数和颗粒细度,介绍了光学波动法测量固相质量分数的基本原理,并在气固两相流实验台上采用基于光学波动法的激光探针测量固相质量分数,对不同的一、二次配风条件下的回流区大小、扩散特性以及质量分数分布变化进行了测量研究.试验结果表明：在燃烧器出口流场中,固相质量分数最高点和气相速度的最高点均处于二次风口附近,在离燃烧器出口0~200 mm范围内,气相速度衰减迅速,而固相质量分数的衰减缓慢；各次风对固相质量分数分布的作用各不相同：一次风大小的改变对中心回流区内固相质量分数影响微弱,主要影响周边区域；增强内二次风对增强回流区内的固相质量分数的差异最为明显；增加外二次风限制了颗粒对外扩散,固相质量分数的分布在周向上更加均匀.
Abstract:

In order to measure the particle concentration and diameter distribution precisely, the principles of particle concentration measurement by the optical wave method were firstly introduced, and then the method was employed to investigate the particle concentration out of a swirl burner on a gas-solid test rig. The scale of recirculation zone, particle diffusion characteristics and particle concentrations in the flows at different cross-sections under various primary air and secondary air ratios were measured. The test results show that the zones of high solid-phase mass fraction are overlapped by those of high gas velocity, and all these zones are located close to exit of secondary air. Within 0~200 mm to the outlet of swirl burner, the attenuation of gas velocity is fast while the solid-phase mass fraction has little change. The influences of each air on particle distributions are different. Primary air has little influence on the concentration in the recirculation zone, but affects the peripheral region greatly. The enhancing of the inner secondary air will increase the concentration differences in the recirculation zone. The enhancing of the outer secondary air would limit particles external diffusion, resulting in the concentration distribution well~distributed at circumferential direction.
出版日期: 2012-12-01
:  TK 222  
基金资助:

国家重点基础研究发展计划资助项目（2009CB219802）|国家科技支撑计划资助项目（2011BAA04B01）|全国优秀博士学位论文作者专项资金资助项目(200747).
作者简介: 周昊（1973—）,男,教授,博导,从事煤的低污染优化燃烧技术研究.E-mail: zhouhao@cmee.zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

周昊, 吴剑波, 杨玉, 李亚鹏, 胡善涛, 岑可法. 旋流燃烧器出口气固两相流场的
光学波动法测量研究[J]. J4, 2012, 46(12): 2189-2193.

ZHOU Hao, WU Jian-bo, YANG Yv, LI Ya-peng, HU Shan-tao, CEN Ke-fa. Experimental measurement of gas-solid two-phase flow of
a swirl burner by optical wave method. J4, 2012, 46(12): 2189-2193.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2012.12.008    或    http://www.zjujournals.com/eng/CN/Y2012/V46/I12/2189

［1］ ZHOU Hao, CEN Kefa. Experimental investigations on performance of collisionblocktype fuelrich/lean burner: influence of solid concentration［J］.Energy & Fuels, 2007,21(2): 718-727.
［2］ 容銮恩,袁镇福,刘志敏,等.电站锅炉原理［M］.北京:中国电力出版社,1997: 380.
［3］ 丘纪华,邹春,刘敬樟,等.旋流型O2/CO2煤粉燃烧器的流动及燃烧试验研究［J］.中国电机工程学报,2010,30(17): 1-5.
QIU Jihua, ZOU Chun, LIU Jingzhang, et al. Experimental study of O2/CO2 swirled burner of pulverized coal on flow field and combustion［J］. Proceedings of the CSEE, 2010,30(17): 1-5.
［4］ 李洪涛,阎维平,叶学民,等.自吸式飞灰等速取样枪的气体动力学分析［J］.热力发电,2006(3): 19-22.
LI Hongtao,YAN Weiping,YIE Xuemin,et al. Aerodynamics analysis of selfsuction type isovelocity fly ash sampling gun［J］. Thermal Power Generation, 2006(3): 19-22.
［5］ 胡红利,周屈兰,徐通模,等.电容式气固两相流浓度测量系统［J］.仪器仪表学报,2007,28(11): 1947-1950.
HU Hongli, ZHOU Qulang, XU Tongmo, et al. Capacitancebased system for solid concentration measurement in gas/solid twophase flow［J］. Chinese Journal of Scientific Instrument, 2007,28(11): 1947-1950.
［6］ 张朴,孔力,黄心汉,等.一种气动传输粉体质量流量测量方法［J］.华中科技大学学报,2001(8): 47-49.
ZHANG Pu, KONG Li, HUANG Xinhan, et al. A method for the mass flow rate measurement of pulverized material in pneumatic pipeline［J］. Journal of Huazhong University of Science and Technology, 2001(8): 47-49.
［7］ 蔡小舒,潘咏志,欧阳新,等.电厂煤粉管道中煤粉运行状况诊断研究［J］.中国电机工程学报,2001(7): 84-87.
CAI Xiaoshu, PAN Yongzhi, OUYANG Xin, et al. The study of diagnosing the running condition of pulverized coal in pipe［J］. Proceedings of the CSEE, 2001(7): 84-87.
［8］ DMOWSKA Renate,SALTZMAN Barry. Advance in Geophysics［M］. San Diego, Califormia: Academia Press,1993.
［9］ 周昊.大型电站锅炉氮氧化物控制和燃烧优化中若干关键性问题的研究［D］.杭州:浙江大学,2004.
ZHOU Hao. Investigation on NOx control and combustion optimization for large capacity utility boilers［D］. Hangzhou: Zhejiang University, 2004.
［10］ ZHOU Hao, CEN Kefa. Experimental measurements of a gassolid jet downstream of a fuelrich/lean burner with a collisionblocktype concentrator［J］.Powder Technology,2006,170(2): 94-107.
［11］ 王卫良,崔凯,张海,等.颗粒粒径对旋流燃烧器出口流场作用的实验研究［J］.中国科技论文在线,2010(11): 840-845.
WANG Weiliang, CUI Kai, ZHANG Hai, et al. Experimental study on the effect of particle size on the exit flow field of a swirl burner［J］.Sciencepaper Online,2010(11): 840-845.
［12］ 周志军,周丛丛,许建华,等.低NOx旋流燃烧器一、二次风混合特性分析［J］.中国电机工程学报, 2010(11): 8-14.
ZHOU Zhijun,ZHOU Congcong,XU Jianhua, et al.Analysis of the mixing between primary air and secondary air in a low NOx swirl burner［J］. Proceedings of the CSEE, 2010(11): 8-14.
[1] 沈跃良,周昊 ,胡敏 ,杨玉 ,吴剑波 ,岑可法. 静电网格系统在旋流燃烧器流场测量中的应用[J]. J4, 2013, 47(9): 1658-1665.