Please wait a minute...
浙江大学学报(工学版)
J4  2010, Vol. 44 Issue (9): 1838-1844    DOI: 10.3785/j.issn.1008-973X.2010.09.033
交通运输、一般工业技术     
跨临界CO2压缩喷射系统稳定性实验研究
徐肖肖,唐黎明,朱治江,梁利霞,陈光明
浙江大学 制冷与低温研究所, 浙江 杭州 310027
Experimental study of working stability in transcritical CO2
compression-ejection system
XU Xiao-xiao, TANG Li-ming, ZHU Zhi-jiang, LIANG Li-xia, CHEN Guang-ming
Institute of Refrigeration and Cryogenics, Zhejiang University, Hangzhou 310027, China
 全文: PDF  HTML
摘要：

为了研究跨临界CO2压缩喷射系统的稳定性,在自行搭建的实验台上进行了改变工作环境参数及调节节流阀开度对系统稳定性影响的实验.通过分析实验工况下工作流体压力、引射流体压力、背压、工作流体流量、引射流体流量、喷射系数和升压比的变化趋势,得出以下系统稳定性规律：当冷却水流量变化或节流阀开度变化时,系统将从一个稳定状态过渡到另一个稳定状态,在过渡阶段系统处于不稳定状态；当节流阀开度接近全开（90%）时,工作流体压力将超过压力极限,工作流体流量将达到压缩机的阻塞工况,系统越来越偏离稳定工况,必须及时关闭系统；当节流阀开度接近全关（5%）时,引射流体流量不断减小,最终减小为零,喷射器不再卷吸引射流体,必须及时关闭系统.
Abstract:

Experiments were performed to reveal the influences of operating conditions and throttle opening on working stability of the transcritical CO2 compressionejection system. Through analysis of the trends in primary flow pressure, entrained flow pressure, back pressure, primary flow rate, entrained flow rate, entrainment ratio, and pressure lift, the following characteristics of system stability were determined. Changes in cooling water flow rate or throttle opening can cause the system to transition from one stable state to another. It can behave in an unstable way during the transition. When the throttle is nearly full open (90%), the primary pressure is near the highpressure limit. The primary flow reaches choke condition of the compressor. The system becomes unstable and must be shut down. When the throttle opening is nearly full closed (5%), the flow rate of the entrained fluid decreases until to zero. The ejector no longer entrains this fluid. The system becomes unstable and must be shut down．
出版日期: 2010-09-01
:  TB 61  
基金资助:

国家科技支撑计划资助项目(2006BAJ01A10)；浙江省重大科技专项资助项目（2007C01002）
通讯作者: 陈光明, 男, 教授.     E-mail: gmchen@zju.edu.cn
作者简介: 徐肖肖(1980-), 女, 浙江温州人,博士生,从事CO2热泵热水器系统方面的研究. E-mail: xuxiaoxiao19@126.com
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

徐肖肖, 唐黎明, 朱治江, 梁利霞, 陈光明. 跨临界CO2压缩喷射系统稳定性实验研究[J]. J4, 2010, 44(9): 1838-1844.

XU Xiao-Xiao, TANG Li-Meng, SHU Chi-Jiang, LIANG Li-Xia, CHEN Guang-Meng. Experimental study of working stability in transcritical CO2
compression-ejection system. J4, 2010, 44(9): 1838-1844.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2010.09.033    或    http://www.zjujournals.com/eng/CN/Y2010/V44/I9/1838

［1］ ROBINSON D M, GROLL E A. Efficiencies of transcritical CO2 cycles with and without an expansion turbine ［J］. International Journal of Refrigeration, 1998, 21 (7): 577589．
［2］ ElBEL S W, HRNJAK P S. Experimental validation of a prototype ejector designed to reduce throttling losses encountered in transcritical R744 system operation ［J］. International Journal of Refrigeration, 2008, 31(3): 411422．
［3］ OZAHI Y, TAKEUCHI H, HIRATA T. Regeneration of expansion energy by ejector in CO2 cycle［C］∥ Sixth IIR/IIF Gustav Lorentzen Conference on Natural Working Fluids. Glasgow, Scotland: 2004, ISBN 2913149340．
［4］ 刘军朴,陈江平,陈芝久. 跨临界二氧化碳蒸汽压缩/喷射制冷循环［J］.上海交通大学学报,2004, 38(2): 273275．
LIU Junpu, CHEN Jiangpin, CHEN Zhijiu. Thermodynamic analysis on CO2 transcritical vaporcompression/ejection refrigeration cycle ［J］. Journal of Shanghai Jiaotong University, 2004, 38(2): 273275.
［5］ 马一太, 管海清, 杨俊, 等. CO2双蒸发器压缩/喷射式跨临界制冷循环［J］. 太阳能学报, 2006, 27(1): 7377．
MA Yitai, GUAN Haiqing, YANG Junlan, et al. CO2 trancritical compression/ejection hybrid refrigeration cycle with two evaporators ［J］. Acta Energiae Solaris Sinica, 2006, 27(1): 7377．
［6］ KORNHAUSER A A. The use of an ejector as a refrigerant expander［C］∥ Proceedings of the 1990 USNC/IIR Purdue Refrigeration Conference.  West Lafayette,IN, USA: Purdue University,1990:1019．
［7］ LI D Q, GROLL E A. Transcritical CO2 refrigeration cycle with ejectorexpansion device ［J］. International Journal of Refrigeration, 2005, 28(5): 766773．
［8］ DENG J Q, JIANG P X, LU T, et al. Particular characteristics of transcritical CO2 refrigeration cycle with an ejector ［J］. Applied Thermal Engineering, 2007, 27(2/3): 381388．
［9］ 李涛, 孙民, 李强, 等. 利用喷射提高跨临界二氧化碳系统的性能［J］. 西安交通大学学报, 2006, 40(5): 553557．
LI Tao, SUN Min, LI Qiang, et al. Performance of transcritical carbon dioxide system with ejector ［J］. Journal of Xian Jiaotong University, 2006, 40(5): 553557．
［10］ HUBACHER B, GROLL E A. Measurement of performance of carbon dioxide compressors ［EB/OL］.［20021101］.http:∥artiresearch.org/research/completed/finalreports/10070final.pdf.
[1] 陈琪, 佟杨, 朱治江, 唐黎明, 陈光明, 李建军. CO2空气源热泵热水器的实验研究[J]. J4, 2012, 46(4): 610-615.