Please wait a minute...
浙江大学学报(工学版)
浙江大学学报(工学版)  2017, Vol. 51 Issue (10): 1959-1966    DOI: 10.3785/j.issn.1008-973X.2017.10.009
机械与能源工程     
水泥窑尾粉尘性质对高温静电捕集的影响规律
严佩, 翁卫国, 郑成航, 许希, 沈之旸, 高翔, 倪明江, 岑可法
浙江大学 能源清洁利用国家重点实验室, 浙江 杭州 310027
Experimental study on cement kiln dust removal by high-temperature electrostatic precipitator
YAN Pei, WENG Wei-guo, ZHENG Cheng-hang, XU Xi, SHEN Zhi-yang, GAO Xiang, NI Ming-jiang, CEN Ke-fa
State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China
 全文: PDF(1920 KB)   HTML
摘要：

建立高温线板式静电除尘实验系统，将某干法水泥窑尾粉尘作为实验样品，测试粉尘比电阻.通过X射线荧光分析、场发射扫描电镜及马尔文激光粒度仪分析粉尘的化学成分、形貌及粒径分布特性，研究373~773 K下静电除尘器对水泥窑尾粉尘的脱除规律.结果表明：水泥窑尾粉尘CaO质量分数高达42.91%，K2O与Na2O质量分数低至0.57%、0.16%，导致粉尘比电阻的最高值达到1.75×1013 Ω·cm.粉尘脱除效率随温度的升高先下降后上升，在423~673 K高比电阻段（>1012 Ω·cm），粉尘脱除效率低于90%.水泥窑尾粉尘PM1.0颗粒粒子数密度约占颗粒总数目的87.5%，373 K下，PM1.0脱除效率为82.1%，明显低于PM2.5、PM10脱除效率的95.1%、95.7%，但高温强化了细颗粒的扩散荷电；773 K下，PM1.0脱除效率与PM2.5、PM10的差距减小.增大比收尘面积可以有效地提高高温下水泥窑尾粉尘的脱除效率.
Abstract:

A wire-plate electrostatic precipitator was constructed to analyze the particle collection characteristics from 373 K to 773 K. The resistivity, chemical composition, morphology and particle size distribution of cement kiln ash were analyzed. Results show that CaO mass fraction of the cement kiln dust is 42.91%, and Na2O/K2O mass fraction is 0.57%/0.16%, the maximum resistivity is 1.75×1013 Ω·cm at 453 K. Particle removal efficiency first decreases, and then increases with the increasing temperature. The removal efficiency is below 90% at temperatures from 423 K to 673 K, because ash resistivity under these temperatures is larger than 1012 Ω·cm. The number fraction of PM1.0 is 87.5% to the total cement kiln fly ash particles, and the removal efficiency of PM1.0 is 82.1% at 373 K, much lower than 95.1%、95.7% for PM2.5 and PM10. PM2.5 and PM10 removal efficiencies decrease more rapidly with the increasing temperature than PM1.0, for high temperature strengthens diffusion charge of fine particles. Cement kiln ash removal efficiency can be improved by enlarging the specific collecting area of high-temperature electrostatic precipitator (ESP).
收稿日期: 2016-07-22 出版日期: 2017-09-27
CLC:  TK411  
基金资助:

杭州市产学研合作资助项目（G20150101）；中央高校基本科研资助项目（2016FZA4009）；国家“973”重点基础研究发展规划资助项目（2013CB228504）；国家“863”科技支撑计划资助项目（2015BAA05B02）.
通讯作者: 高翔,男,教授,博导.     E-mail: xgao1@zju.edu.cn
作者简介: 严佩(1988-),女,博士生,从事高温气体中颗粒物静电捕集研究.ORCID:0000-0002-4702-9850.E-mail:yanpei966@zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
作者相关文章　　

引用本文:

严佩, 翁卫国, 郑成航, 许希, 沈之旸, 高翔, 倪明江, 岑可法. 水泥窑尾粉尘性质对高温静电捕集的影响规律[J]. 浙江大学学报(工学版), 2017, 51(10): 1959-1966.

YAN Pei, WENG Wei-guo, ZHENG Cheng-hang, XU Xi, SHEN Zhi-yang, GAO Xiang, NI Ming-jiang, CEN Ke-fa. Experimental study on cement kiln dust removal by high-temperature electrostatic precipitator. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 2017, 51(10): 1959-1966.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2017.10.009    或    http://www.zjujournals.com/eng/CN/Y2017/V51/I10/1959

[1] 刘巍巍.浅谈大气细颗粒物污染的危害及防治对策[J].绿色科技,2014, 3(3):97-98. LIU Wei-wei. Analysis of hazards and countermeasures for prevention and control of atmospheric fine particles pollution[J]. Journal of Green Science and Technology, 2014, 3(3):97-98.
[2] 钱孝琳,阚海东,宋伟民,等.大气细颗粒物污染与居民每日死亡关系的Meta分析[J].环境与健康杂志,2005, 22(4):246-248. QIAN Xiao-lin, KAN Hai-dong, SONG Wei-ming, et al. Meta-analysis of association between air fine particulate matter and daily mortality[J]. Journal of Environment Health, 2005, 22(4):246-248.
[3] 阚海东.雾霾天气下的细颗粒物污染和居民健康[J].中华预防医学杂志,2013,47(6):491-493. KAN Hai-dong. Fine particulate matter pollution and the residents health in foggy weather[J]. Chinese Journal of Preventive Medicine, 2013, 47(6):491-493.
[4] PAN W C, WU C D, CHEN M J, et al. Fine particle pollution, alanine transaminase, and liver cancer:a taiwanese prospective cohort study[J]. Jnci-Journal of the National Cancer Institute, 2016, 108(3):27-35.
[5] ZYRKOWSKI M, NETO R C, SANTOS L F, et al. Characterization of fly-ash cenospheres from coal-fired power plant unit[J]. Fuel, 2016(174):49-53.
[6] 赵磊,周洪光.超低排放燃煤火电机组湿式电除尘器细颗粒物脱除分析[J].中国电机工程学报,2016,36(2):468-473. ZHAO Lei, ZHOU Hong-guang. Particle removal efficiency analysis of WESP in an ultra low emission coal-fired power plant[J]. Proceedings of the CSEE, 2016, 36(2):468-473.
[7] CASTLE G S P. A century of development in appliedelectrostatics; nothing static here[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2011, 18(5):1361-1365.
[8] 陈柏林.2013年水泥行业经济运行报告[J].中国水泥,2014(1):23-29. CHEN Bo-lin. 2013 Economic operation report of cement industry[J]. China Cement, 2014(1):23-29.
[9] 李小龙.新型干法水泥窑烟气特点及除尘技术[J].中国水泥,2013(4):72-73. LI Xiao-long. Flue gas characteristics of new dry process cement kiln and dust removal technology[J]. China Cement, 2013(4):72-73.
[10] 陈春侠,黄素平,邱培培,等.高温滤料在袋式除尘中的应用及性能[J].合成纤维工业,2014,37(5):61-64. CHEN Chun-xia, HUANG Su-ping, QIU Pei-pei, et al. Application and performance of high-temperature filter media in bag-house duster[J]. China Synthetic Fiber Industry, 2014, 37(5):61-64.
[11] 张楠,崔鑫,靳向煜,等.加固工艺及组分对PPS/PTFE复合耐高温滤料性能的影响[J].东华大学学报:自然科学版,2014, 40(2):202-205. ZHANG Nan, CUI Xin, JIN Xiang-yu, et al. Effect of forming process and component to PPS/PTFE composite high temperature resistance filter[J]. Journal of Donghua University:Natural Science, 2014, 40(2):202-205.
[12] SHALE C. Progress in high-temperature electrostatic precipitation[J]. Journal of the Air Pollution Control Association, 1967, 17(3):159-160.
[13] VILLOT A, GONTHIER Y, GONZE E, et al. Separation of particles from syngas at high temperatures with an electrostatic precipitator[J]. Separation and Purification Technology, 2012(92):181-190.
[14] NODA N, MAKINO H. Influence of operating temperature on performance of electrostatic precipitator for pulverized coal combustion boiler[J]. Advanced Powder Technology, 2010, 21(4):495-499.
[15] FULYFUL F K. High temperature high pressure effect on performance of an electrostatic precipitator[J]. Journal of Kerbala University, 2008, 6(2):84-92.
[16] LANZERSTORFER C, FEICHTINGER K. Cement kiln dust:characterization of dust collected in various fields of electrostatic precipitators[J]. Environmental Engineering Science, 2016, 33(3):200-206.
No related articles found!