Please wait a minute...
浙江大学学报(工学版)
浙江大学学报(工学版)
土木工程     
TBM盘形滚刀切削饱水岩石试验研究
谭青, 张逸超, 夏毅敏, 高浩
1. 中南大学 高性能复杂制造国家重点实验室,湖南 长沙 410083； 
2. 中南大学 机电工程学院,湖南 长沙 410083；
3. 中南大学 轻合金研究院,湖南 长沙 410083
Experimental research of TBM disc cutter penetrate saturated rock
TAN Qing, ZHANG Yi-chao, XIA Yi-min, GAO Hao
1.State Key Laboratory of High Performance Complex Manufacturing, Central South University, Changsha 410083, China； 
2. School of Mechanical and Electrical Engineering, Central South University, Changsha 410083, China； 
3. Light Alloy Institute, Central South University, Changsha 410083, China
 全文: PDF(6128 KB)   HTML
摘要：

为了研究不同类型（软岩-硬岩,高孔隙率-低孔隙率）岩石饱水情况下全断面岩石掘进机（TBM）盘形滚刀的切削特性,选用砂岩、花岗岩、板岩、石灰华、混凝土5种岩石开展干燥条件与饱水条件下的滚刀切削破碎试验和破碎块筛分实验,并利用三向力传感器对侵入过程中的侵入力进行测定.对比分析滚刀切削过程的侵入力-侵深曲线、破碎块特征以及破碎比能耗等规律.试验结果表明：饱水后岩石强度下降6%~27%；饱水后岩石侵入系数较干燥条件下的降幅与岩石吸水率呈正相关性,Pearson相关系数为0.957；混凝土和石灰华干燥条件下瞬间破碎,而在饱水条件下抑制了裂纹的扩展；饱水后岩石破碎块度增大,硬岩在饱水后的破岩量下降,软岩破岩量增加；饱水后硬岩破碎的比能耗下降明显,平均下降37.8%,软岩的破碎比能耗上升,其中混凝土饱水后比能耗升高20%,石灰华升高81.6%.
Abstract:

In order to analyze the tunneling boring machine disc cutter penetration features of different types of rock (hard-soft, high porosity-low porosity) under saturate condition, five kinds of dry/saturated rock samples (sandstone, granite, slate, travertine, concrete) were chosen to conduct the disc cutter penetration test and broken rock slag screening experiment.Force sensors were used to invade the invasion force. Characteristics of load-penetration curve, broken pieces as well as the energy consumption were analyzed. Test results show that the rock strength was reduced 6%-27% after saturated.The decreasing range of invasion coefficient between saturated and dry was positive correlation with water absorption, and the Pearson correlation coefficient was 0.957.Water inhibited the crack propagation of travertine and concrete, while under dry condition crack broken in instant.Rock breakage degree was increased after saturated, the amount of hard rock broken piece after saturated dropped, soft rock was increased.Hard rock specific energy decreased 37.8% after saturated, while soft was increased after saturated, travertine and concrete specific energy increased 81.6% and 20% respectively.
出版日期: 2017-05-01
CLC:  TU 433  
基金资助:

国家“973”重点基础研究发展计划资助项目（2013CB035401）；国家自然科学基金资助项目（51475478,51274252,51074180）；湖南省科技重大专项资助项目（2014FJ1002）.
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
作者相关文章　　

引用本文:

谭青, 张逸超, 夏毅敏, 高浩. TBM盘形滚刀切削饱水岩石试验研究[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2017.05.010.

TAN Qing, ZHANG Yi-chao, XIA Yi-min, GAO Hao. Experimental research of TBM disc cutter penetrate saturated rock. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2017.05.010.

参考文献(References)：
［1］ 王梦恕.中国盾构和掘进机隧道技术现状、存在的问题及发展思路［J］.隧道建设,2014,34(3): 179-187.
WANG Meng-shu. Tunneling by TBM/shield in China: state-of-art, problems and proposals［J］. Tunnel Construction,2014,34(3): 179-187.
［2］ 施虎,杨华勇,龚国芳,等.盾构掘进机关键技术及模拟试验台现状与展望［J］.浙江大学学报:工学版,2013,47(5): 741-749.
SHI Hu, YANG Hua-yong, GONG Guo-fang, et al. Key technologies of shield tunneling machine and present status and prospect of test rigs for tunneling simulation.［J］. Journal of Zhejiang University: Engineering Science, 2013,47(5): 741-749.
［3］ ROSTAMI J. Study of pressure distribution within the crushed zone in the contact area between rock and disc cutters ［J］. International Journal of Rock Mechanics and Mining Sciences, 2013, 57(1): 172-186.
［4］ CHO J W, JEON S, JEONG H Y, et al. Evaluation of cutting efficiency during TBM disc cutter excavation within a Korean granitic rock using linear-cutting-machine testing and photogrammetric measurement ［J］. Tunnelling & Underground Space Technology, 2013, 35(4): 37-54.
［5］ 谭青,李建芳,夏毅敏,等.盘形滚刀破岩过程的数值研究［J］.岩土力学,2013,34(9): 2707-2714.
TAN Qing, LI Jian-fang, XIA Yi-min, et al. Numerical research on rock fragmentation process by disc cutter ［J］.Rock and Soil mechanics, 2013, 34(9): 2707-2714.
［6］ 李刚,王宛山.全断面岩石掘进机滚刀间距优化研究［J］.哈尔滨工程大学学报,2013,34(7): 913-917.
LI Gang,WANG Wanshan. Study on optimum spacing of TBM disc cutters ［J］.Journal of Harbin Engineering University, 2013, 34(7): 913-917.
［7］ 张魁,夏毅敏,谭青,等.不同围压条件下TBM刀具破岩模式的数值研究［J］.岩土工程学报,2010, 32(11): 1780-1787.
ZHANG Kui, XIA Yi-min, TAN Qing, et al. Numerical study on modes of breaking rock by TBM cutter under different confining pressures ［J］.Chinese Journal of Geotechnical Engineering,2010, 32(11): 1780-1787.
［8］ CHOI S O, LEE S J. Numerical study to estimate the cutting power on a disc cutter in jointed rock mass ［J］. KSCE Journal of Civil Engineering, 2016, 20(1): 1-12.
［9］ 刘建琴,刘蒙蒙,郭伟.硬岩掘进机盘型滚刀回转破岩仿真研究［J］.机械工程学报,2015, 51(9): 199-205.
LIU Jian-qin, LIU Meng-meng, GUO Wei. Research on the simulation of cutting rock rotary by hard rock tunnel boring machine disc cutters ［J］.Journal of mechanical engineering, 2015,51(9): 199-205.
［10］ 邹飞, 李海波, 周青春,等. 岩石节理倾角和间距对隧道掘进机破岩特性影响的试验研究［J］. 岩土力学, 2012, 33(6): 1640-1646.
ZOU Fei, LI Hai-bo, ZHOU Qing-chun, et al. Experimental study of influence of joint space and joint angle on rock fragmentation by TBM disc cutter ［J］.Rock and Soil Mechanics, 2012,33(6): 1640-1646.
［11］ 李天斌,陈子全,陈国庆,等.不同含水率作用下砂岩的能量机制研究［J］.岩土力学,2015(S2): 229-236.
LI Tian-bin, CHEN Zi-quan, CHEN Guo-qing, et al. An experimental study of energy mechanism of sandstone with different moisture contents ［J］. Rock and Soil Mechanics, 2015(S2): 229-236.
［12］ MA H, YIN L, JI H. Numerical study of the effect of confining stress on rock fragmentation by TBM cutters［J］.International Journal of Rock Mechanics and Mining Sciences,2011,48(6): 1021-1033.
［13］ MOON T, Oh J. A study of optimal rock-cutting conditions for hard rock TBM using the discrete element method ［J］. Rock Mechanics and Rock Engineering, 2012, 45(5): 837-849.
［14］ 陈立宪, 黄国忠, 陈尧中,等. 岩体贯切破坏在不同侧向自由边界的声发射演化［J］. 岩石力学与工程学报, 2009, 28(12): 2411-2420.
CHEN Lihsien, HUANG Kuochung, CHEN Yaochung. Acoustic emission evolution in indentation fracture of rocks under different lateral stress-free boundaries ［J］. Chinese Journal of Rock Mechanics and Engineering,2009, 28(12):2411-2420.
［15］ ZHANG Z, GAO F. Experimental investigation on the energy evolution of dry and water-saturated red sandstones ［J］. International Journal of Mining Science and Technology, 2015, 25(3):383-388.
［16］ 朱明礼,朱珍德,唐胡丹,等.深埋隧洞围岩双向流变特性试验［J］.煤炭学报,2010(2): 208-212.
ZHU Ming-li, ZHU Zhen-de, TANG Hu-dan, et al. The experimental on the biaxial rheological characteristics of the surrounding rock of deep buried tunnel ［J］. Journal of China Coal Society, 2010(2): 208-212.
［17］ 王石春，何发亮，李苍松.隧道工程岩体分级［M］.西南交通大学出版社,2007: 74-99.
［18］ 熊德国,赵忠明,苏承东,等.饱水对煤系地层岩石力学性质影响的试验研究［J］.岩石力学与工程学报,2011,30(5): 998-1006.
XIONG Deguo, ZHAO Zhongming, SU Chengdong, et al. Experimental study of effect of water-saturated state on mechanical properties of rock in coal measure strata ［J］. Chinese Journal of Rock Mechanics and Engineering, 2011, 30(5):998-1006.
［19］ GERTSCH R, GERTSCH L, ROSTAMI J. Disc cutting tests in Colorado Red Granite: Implications for TBM performance prediction ［J］. International Journal of Rock Mechanics and Mining Sciences, 2007, 44(2): 238-246.
［20］ 张春会.饱水度对砂岩模量及强度的三轴试验［J］.岩土力学,2014,35(4): 951-958.
ZHANG Chunhui. Triaxial tests of effects of varied saturations on strength and modulus for sandstone ［J］. Rock and Soil Mechanics, 2014, 35(4): 951-958.
［21］ 盛佳韧,叶冠林,王建华. 软岩地下洞库施工的水土耦合有限元模拟［J］.浙江大学学报：工学版,2014,46(5): 785-790.
SHENG Jia-ren,YE Guan-lin,WANG Jian-hua. Soil-water coupled numerical simulation on undergroundcavern excavation in soft rock grond ［J］. Journal of Zhejiang University ：Engineering Science, 2014,46(5):785-790.
［22］ 郭春.特长TBM施工隧道环境粉尘安全控制研究［J］.工业环境与安全,2015,41(7): 63-66
GUO Chun. Study on the dust control of the construction environment safety in extra-long tunnel driven by TBM ［J］. Industrial Safety and Environmental Protection, 2015, 41(7): 63-66.
[1] 丁绚晨,陈育民,张鑫磊. 微生物加固钙质砂环剪试验研究[J]. 浙江大学学报(工学版), 2020, 54(9): 1690-1696.
[2] 李飞, 朱鸿鹄, 张诚成, 施斌. 地基变形光纤光栅监测可行性的试验研究[J]. 浙江大学学报(工学版), 2017, 51(1): 204-211.
[3] 许烨霜, 沈水龙, 马磊. 地下构筑物对地下水渗流的阻挡效应[J]. J4, 2010, 44(10): 1902-1906.
[4] 苏万鑫, 谢康和. 土水特征曲线为直线的非饱和土一维固结计算[J]. J4, 2010, 44(1): 150-155.