Please wait a minute...
浙江大学学报(工学版)
浙江大学学报(工学版)
电气工程     
基于多电容充放电平衡的多路输出LED驱动器
胡晨, 吴新科, 彭方正, 钱照明
浙江大学 电气工程学院, 浙江 杭州 310027
Multi-output LED driver with charge balance in multi-capacitors
HU Chen, WU Xin-ke, PENG Fang-zheng, QIAN Zhao-ming
College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China
 全文: PDF(3435 KB)   HTML
摘要：

为解决多路并联发光二极管（LED）的均流问题,提出一种利用多个均流电容充放电平衡原理的多路LED均流方法.该方法将多个均流电容与变压器不同副边绕组互相串联,通过多个均流电容的串联耦合和均流电容的安秒平衡原理实现多路LED均流.在此基础上,结合LLC拓扑和副边均流电容,构建四路输出的LLCC谐振LED驱动器.详细分析了驱动器在一个开关周期内的工作模态及多电容均流机理,并通过将多路副边输出简化和等效为单路输出,得到电路的直流增益曲线,并给出驱动器的设计原则.研制了一台功率为150 W,每路输出电流为0.35 A的四路输出LED驱动器样机,试验结果表明：在驱动器的均流范围内,流过变压器副边绕组的电流幅度一致,相位一致或相反,保证了各路LED负载的精确均流.
Abstract:

A multi-channel light-emitting diode(LED) current sharing method utilizing the charge balance of block capacitors was proposed to solve the current sharing issue when LED strings are paralleled. The block capacitors are in series with the corresponding secondary side windings of the transformer. By coupling the block capacitors in series, plus with amp-second balance, accurate current sharing among output LED strings is achieved. A four-output LLCC LED driver was constituted by combining the block capacitors and the LLC topology in primary side. The operating modes in one switching cycle are presented. The current sharing principle was also analyzed. By merging four outputs into one, the characteristic gain curves could be concluded for the circuit design guidance. A 150 W four-channel output prototype with 0.35 A/channel was built up. The amplitudes of the current waveforms in secondary side windings were identical and the phases were identical or opposite in the current sharing range, thus accurate current sharing was realized.
出版日期: 2014-12-01
:  TM 46  
基金资助:

国家自然科学基金资助项目（51007081）；中央高校基本科研业务费专项资金资助项目(2013QNA4022)；台达环境与教育基金会《电力电子科教发展计划》资助项目.
通讯作者: 吴新科，男，副教授     E-mail: wuxinke@zju.edu.cn
作者简介: 胡晨（1987—），男，博士生，从事高效率LED驱动器及DC-DC变流器研究.E-mail：huchen@zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

胡晨, 吴新科, 彭方正, 钱照明. 基于多电容充放电平衡的多路输出LED驱动器[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2014.12.014.

HU Chen, WU Xin-ke, PENG Fang-zheng, QIAN Zhao-ming. Multi-output LED driver with charge balance in multi-capacitors. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2014.12.014.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2014.12.014    或    http://www.zjujournals.com/eng/CN/Y2014/V48/I12/2202

［1］ 倪建军, 张方华, 俞忆洁. 无电解电容的高功率因数AC-DC LED驱动器［J］. 电工技术学报, 2012, 27(12): 79-86.
NI Jian-jun, ZHANG Fang-hua, YU Yi-jie. High power factor AC-DC LED drivers without electrolytic capcitors［J］. Transactions of China Electrotechnical Society, 2012, 27(12): 79-86.
［2］ CHEN C, WU C, CHEN Y, et al. Sequential color LED backlight driving system for LCD panels［J］. IEEE Transactions on Power Electronics, 2007, 22(3): 919-925.
［3］ HWU K I, YAU Y T, LEE L. Powering LED using high-efficiency SR flyback converter［C］∥ Applied Power Electronics Conference and Exposition (APEC). Washington, DC: IEEE, 2009: 563-569.
［4］ ZHANG J, WANG J, WU X. A Capacitor-isolated LED driver with inherent current balance capability［J］. IEEE Transactions on Industrial Electronics, 2012, 59(4): 1708-1716.
［5］ 俞忆洁,张方华,倪建军.电容钳位型LED均流电路［J］.电工技术学报,2013, 28(02): 178-184.
YU Yi-jie, ZHANG Fang-hua, NI Jian-jun. Capacitor clamped current sharing circuit for multi-string LEDs［J］. Transactions of China Electrotechnical Society, 2013, 28(02): 178-184.
［6］  GIOVANNI C. Solving high-voltage off-line HB-LED constantcurrent contro-circuit issues［C］∥Applied Power Electronics Conference and Exposition (APEC). Anaheim: IEEE, 2007: 1316-1318.
［7］ CHIU H, LO Y, CHEN J, et al. A high-efficiency dimmable LED driver for low-power lighting applications［J］. IEEE Transactions on Industrial Electronics, 2010, 57(2): 735-743.
［8］ CHIU H, CHENG S. LED Backlight driving system for large-scale LCD Panels［J］. IEEE Transactions on Industrial Electronics, 2007, 54(5): 2751-2760.
［9］ HU Y, JOVANOVIC M M. LED driver with self-adaptive drive voltage［J］. IEEE Transactions on Power Electronics, 2008, 23(6): 3116-3125.
［10］ LI S, ZHONG W, CHEN W, et al. Novel self-configurable current-mirror techniques for reducing current imbalance in parallel light-emitting diode (LED) Strings［J］. IEEE Transactions on Power Electronics, 2012, 27(4): 2153-2162.
［11］ HU Q, ZANE R. LED driver circuit with series-input-connected converter cells operating in continuous conduction mode［J］. IEEE Transactions on Power Electronics, 2010, 25(3): 574-582.
［12］ HWU K I, CHOU S. A Simple current-balancing converter for LED lighting［C］∥Applied Power Electronics Conference and Exposition (APEC).Washington, DC: IEEE, 2009: 587-590.
［13］ CHOI S, KIM T. Symmetric current-balancing circuit for LED backlight with dimming［J］. IEEE Transactions on Industrial Electronics, 2012, 59(4): 1698-1707.
［14］ 唐雄民,张淼,章云,等.一种具有自动均流特性的简易非隔离型多路LED串驱动电路［J］. 电工技术学报, 2013, 28(07): 218-225.
TANG Xiong-min, ZHANG Miao, ZHANG Yun, et al. A simple non-isolated driver with inherent current balancing mechanism for multi-channel LED Strings［J］. Transactions of China Electrotechnical Society, 2013, 28(07): 218-225.
［15］ ZHANG J, XU L, WU X, et al. A precise passive current balancing method for multioutput LED Drivers［J］. IEEE Transactions on Power Electronics, 2011, 26(8): 2149-2159.
［16］ WU X, ZHANG J, QIAN Z. A simple two-channel led driver with automatic precise current sharing［J］. IEEE Transactions on Industrial Electronics, 2011, 58(10): 4783-4788.
［17］ CHEN Y, WU X, QIAN Z. Analysis and design considerations of LLCC resonant Dc-Dc converter with precise current sharing for two-channel LED driver［C］∥Energy Conversion Congress and Exposition (ECCE). Phoenix: IEEE, 2011: 2771-2776.
[1] 胡克用, 胥芳， 艾青林， 徐红伟， 欧阳静. 面向多逆变器的微电网冗余群控策略[J]. 浙江大学学报(工学版), 2016, 50(8): 1608-1617.
[2] 罗辞勇, 魏欣欣, 王卫耀, 南航. 基于耦合电感的零电压零电流软开关Buck变换器[J]. 浙江大学学报(工学版), 2016, 50(4): 663-670.
[3] 张奔奔,胥芳,吴乐彬,艾青林. LCL型并网逆变器自适应谐振抑制[J]. 浙江大学学报(工学版), 2016, 50(1): 180-185.
[4] 胡晨, 吴新科, 彭方正, 钱照明. 变压器级联的双路均流准谐振反激LED驱动器[J]. 浙江大学学报(工学版), 2015, 49(4): 740-748.
[5] 吴中民, 刘威, 吕征宇. LLC全范围满载软开关优化设计[J]. 浙江大学学报(工学版), 2014, 48(12): 2223-2229.
[6] 魏涛, 胡海兵, 陆道荣, 吴红飞. 输入输出电流连续的非隔离直直变换器[J]. 浙江大学学报(工学版), 2014, 48(10): 1901-1908.
[7] 曾争,杨家强. 一种频率自适应滑动平均滤波器的电网同步方法[J]. 浙江大学学报(工学版), 2014, 48(9): 1696-1703.
[8] 胡晨, 吴新科, 彭方正, 钱照明. 基于多电容充放电平衡的多路输出LED驱动器[J]. 浙江大学学报(工学版), 2014, 48(7): 0-.
[9] 张达敏,王仕韬,林辉品,吕征宇. 变拓扑N脉波相控整流器的电流预测控制方法[J]. 浙江大学学报(工学版), 2014, 48(7): 1304-1311.
[10] 郑伟锋,马皓,何湘宁. 基于参数模型辨识的逆变器重复控制[J]. 浙江大学学报(工学版), 2014, 48(5): 896-903.
[11] 廖政伟, 张雪, 尤伟, 姚玮, 吕征宇. 应用于超宽输入范围的变拓扑LLC电路[J]. J4, 2013, 47(12): 2073-2079.
[12] 郑晟, 蔡卓剑, 汪槱生, 钱照明. 适用于IGBT串联系统集成的驱动电路[J]. J4, 2013, 47(12): 2094-2100.
[13] 朱明磊,赵荣祥. 基于快速分布式主从控制的PCS系统[J]. J4, 2013, 47(11): 2031-2037.
[14] 孟培培, 张军明, 钱照明. Boost变流器共模传导干扰建模与预测[J]. J4, 2012, 46(10): 1851-1856.
[15] 孟培培,张军明,陈恒林,钱照明. 反激变流器共模干扰的建模与预测[J]. J4, 2012, 46(9): 1702-1707.