Please wait a minute...
J4  2011, Vol. 45 Issue (1): 185-190    DOI: 10.3785/j.issn.1008-973X.2011.01.032
电气工程     
PWM/PSM双模式高压异步整流BUCK电路
朱丽芳,何乐年,叶益迭
浙江大学 超大规模集成电路设计研究所,浙江 杭州 310027
High voltage PWM/PSM dual-mode asynchronous BUCK converter
ZHU Li-fang, HE Le-nian, YE Yi-die
Institute of VLSI Design, Zhejiang University, Hangzhou 310027, China
 全文: PDF  HTML
摘要:

为了在全负载范围内取得高转换效率,提出一种根据占空比来自动实现模式跳转的脉冲宽度调制(PWM)/跨脉冲调制(PSM)双模式的低功耗、高压直流电压转换电路.它的输入电压为3~24 V,输出电压为2.5~(VIN-0.5)V.当负载电流较大时,芯片采用开关频率为1 MHz的PWM工作模式;当负载电流减小时,采用开关频率降低的PSM模式,从而保证了在全负载电流变化范围内的高转换效率.PWM到PSM模式的跳转采用简单逻辑及最小占空比电路实现,达到了模式的自动转换.电路采用CSMC公司的0.5 μm 40 V高压混合信号模型设计并完成流片加工.测试结果表明,在5 V的输出下,当输入电压到达最大值24 V时,芯片保持了55%以上的转换效率.芯片在2种模式间可以实现平稳过渡,具有良好的负载电流调整特性.

Abstract:

A BUCK converter with high input/output voltage and low power consumption, consisting of two working modes of pulse width modulation (PWM) and pulse skipping modulation (PSM), was proposed in order to obtain high conversion efficiency in the whole load range. The converter automatically skips from PWM to PSM mode by detecting the duty cycle of switch pulse. The input voltage of the converter ranges from 3 V to 24 V, and the output voltage ranges from 2.5 V to (VI-0.5) V. The converter works in PWM-mode at a switching frequency of 1 MHz when the load current is large, and operates in PSM-mode with a reduced switching frequency if the load current is low, which makes a high efficiency in the whole load current range. The PWM/PSM dual-mode converter switches from PWM to PSM mode by limiting the minimum duty cycle, and the mode control circuit was easily realized by some logic gate and one-shot circuit. The chip was implemented by using the CSMC 0.5 μm 40 V mixed-signal process. Experimental results indicate that the efficiency is still higher than 55% when the output voltage is 5 V, even when the input voltage is 24 V which is the highest input voltage of this chip. The chip can smoothly alter mode and display good load regulation.

出版日期: 2011-03-03
:  TN 403  
基金资助:

浙江省重点科技计划资助项目(2007C21021).

通讯作者: 何乐年,男,教授,博导.     E-mail: helenian@vlsi.zju.edu.cn
作者简介: 朱丽芳(1983-),女,浙江上虞人,硕士生,从事直流电压转换器的研究.E-mail:zhulf@vlsi.zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

朱丽芳,何乐年,叶益迭. PWM/PSM双模式高压异步整流BUCK电路[J]. J4, 2011, 45(1): 185-190.

ZHU Li-fang, HE Le-nian, YE Yi-die. High voltage PWM/PSM dual-mode asynchronous BUCK converter. J4, 2011, 45(1): 185-190.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2011.01.032        http://www.zjujournals.com/eng/CN/Y2011/V45/I1/185

[1] CHEN Chilin, HSIEH Weilun. A new PWM/PFM control technique for improving efficiency over wide load range [C]∥Electronics Circuit System, ICECS 2008 15th IEEE International Conference. Malta: IEEE, 2008: 962-965.
[2] ZHANG Xu, MAKSIMOVIC D. Digital PWM/PFM controller with input voltage feedforward for synchronous buck converters [C]∥Applied Power Electronics Conference and Exposition, APEC 2008 23th Annual IEEE. Austin: IEEE, 2008: 523-528.
[3] 刘帘曦,杨银堂,朱樟明. PWM/PFM双模调制的高效率DC/DC开关电源[J]. 固体电子学研究与进展,2006,27(2):209-213.
LIU Lianxi, YANG Yintang, ZHU Zhangming. A high efficiency PWM/PFM dualmode DC/DC switching regulator [J]. Research and Progress of SSE, 2006, 27(2): 209-213.
[4] SANTANU K, SOUMITRO B, AMIT P. Modeling and analysis of DCDC converters under pulse skipping modulation [C]∥ TENCON 2008. IEEE Region 10 Conference. Hyderabad: IEEE, 2008: 1-6.
[5] LUO Ping, LI Zhaoji, XIONG Fugui, et al. Average mode of PSM switching converter and analysis of its characteristics [J]. Transactions of China Electrotechnical Society (China), 2005, 20(3): 19-23.
[6] WANG Jing, GONG Wenchao, HE Lenian. Design and implementation of highefficiency and lowpower DCDC converter with PWM/PFM modes [C]∥ASIC, 2007. ASICON’07. 7th International Conference. Guilin: IEEE, 2007: 596-599.
[7] TELEFUS M. SHTEYNBERG A. FERDOWSI M, et al. Pulse trainTM, a novel digital control method, applied to a discontinuous conduction mode flyback converter [C]∥IEEE 34th Power Electronics Specialist Conference. Acapulco: IEEE, 2003: 1141-1146.
[8] 陈东坡,何乐年,严晓浪. Currentmode DCDC buck converter with high stability and fast dynamic response [J]. 半导体学报,2006, 27(10): 1742-1749.
CHEN Dongpo, HE Lenian, YAN Xiaolang. Currentmode DCDC buck converter with high stability and fast dynamic response [J]. Chinese Journal of Semiconductors, 2006, 27(10): 1742-1749.
[9] 苑婷,何乐年,柯徐刚.离线式开关电源控制器芯片的设计与实现[J].浙江大学学报:工学版,2010,44(11):2130-2136.
YUAN Ting, HE Lenian, KE Xugang. Design and implementation of offline switching powersupply controller [J]. Journal of Zhejiang University: Engineering Science, 2010, 44(11): 2130-2136.

[1] 金津, 何乐年, 陈琛, 叶益迭. 多节串联锂电池的多功能管理芯片设计与实现[J]. J4, 2011, 45(2): 306-313.