Please wait a minute...
浙江大学学报(工学版)
J4  2010, Vol. 44 Issue (4): 761-764    DOI: 10.3785/j.issn.1008-973X.2010.04.024
热能工程、动力与电气工程     
氧化铝纳米流体在车用热交换器中的试验研究
钟勋1, 俞小莉1, 吴俊1, 蒋平灶2
1.浙江大学 动力机械及车辆工程研究所,浙江 杭州 310027； 2.浙江银轮机械股份有限公司,浙江 天台 317200
Experimental investigation on alumina nanofluids in vehicle heat exchanger
ZHONG Xun1, YU Xiaoli1, WU Jun1, JIANG Pingzao2
1. Power Machinery and Vehicular Engineering Institute, Zhejiang University, Hangzhou 310027, China;
2. Zhejiang Yinlun Machinery Co. Ltd, Tiantai 317200, China
 全文: PDF  HTML
摘要：

研究纳米流体在车用热交换器中的强化传热效果,测试不同纳米粒子体积分数的氧化铝纳米流体在板翅式机油冷却器中的传热和流动特性,并与水、防冻液（乙二醇）及纳米流体基础液体进行对比.试验结果表明,在同一热交换器中,纳米流体的传热系数明显高于其他3种液体.当冷、热侧介质温度为90和120 ℃时,纳米粒子体积分数为5%的纳米流体的传热系数分别比水、乙二醇和基础液体提高6.52%、18.88%和24.62%；当冷、热侧介质温度为120和135 ℃时,体积分数为5%的纳米流体的传热系数比体积分数为1%的纳米流体提高104.72%.在试验条件下,热交换器的换热量随纳米粒子体积分数的增大而增大,但流动阻力并未明显增加,初步证明了纳米流体应用于车用热交换器的可行性.
Abstract:

In order to study the heat transfer enhancement of nanofluids in a vehicle heat exchanger (a platefin oil cooler), the heat transfer and flow characteristics of alumina nanofluids with different volume fractions were measured and compared to those of water, antifreeze (ethylene glycol) and nanofluids base fluid. Experimental results showed that in the same heat exchanger, the heat transfer coefficient of nanofluids was significantly higher than that of the other three liquids. When the hot/cold side temperature was 90 ℃/120 ℃, the heat transfer coefficient of 5% (nanoparticle volume fraction) nanofluid increased by 6.52%, 18.88% and 24.62% respectively than that of pure water, antifreeze (ethylene glycol) and base fluid; when the hot/cold side temperature was 120 ℃ /135 ℃, it was 104.72% higher than that of the 1% nanofluid. In the experimental condition, the heat flow increased with the nanoparticle volume fraction, but the flow resistance rose moderately, which primarily proved the feasibility of the nanofluids in the vehicle heat exchanger.
出版日期: 2010-05-14
:  TK124  
通讯作者: 俞小莉，女，教授     E-mail: yuxl@zju.edu.cn
作者简介: 钟勋（1983—），男，浙江嘉兴人，博士生，从事强化传热和车辆热管理研究. E-mail: zhongxun@zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

钟勋, 俞小莉, 吴俊, 蒋平灶. 氧化铝纳米流体在车用热交换器中的试验研究[J]. J4, 2010, 44(4): 761-764.

ZHONG Xun, SHU Xiao-Chi, TUN Dun, JIANG Beng-Zao. Experimental investigation on alumina nanofluids in vehicle heat exchanger. J4, 2010, 44(4): 761-764.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2010.04.024    或    http://www.zjujournals.com/eng/CN/Y2010/V44/I4/761

［1］ CHOI S U S. Enhancing thermal conductivity of fluids with nanoparticles ［J］. ASME FED, 1995, 231: 99103.
［2］ XUAN Y, LI Q. Heat transfer enhancement of nanofluids ［J］. International Journal of Heat and Fluid Flow, 2000, 21(1): 5864.
［3］ KEBLINSKI P, EASTMAN J A, CAHILL D G. Nanofluids for thermal transport ［J］. Materials Today, 2005, 8(6): 3644.
［4］ 彭小飞,俞小莉,钟勋,等.纳米流体热导率试验［J］.浙江大学学报：工学版,2007, 41(7): 11771185.
PENG Xiaofei, YU Xiaoli, ZHONG Xun, et al. Experiments on thermal conductivity of nanofluids ［J］. Journal of Zhejiang University: Engineering Science, 2007, 41(7): 11771185.
［5］ 彭小飞,俞小莉,夏立峰,等.纳米流体悬浮稳定性影响因素［J］.浙江大学学报：工学版,2007, 41(4): 577580.
PENG Xiaofei, YU Xiaoli, XIA Lifeng, et al. Influence factors on suspension stability of nanofluids ［J］. Journal of Zhejiang University: Engineering Science, 2007, 41(4): 577580.
［6］ MAGA S, NGUYEN C T, GALANIS N, et al. Heat transfer behaviours of nanofluids in a uniformly heated tube ［J］. Superlattices and Microstructures, 2004, 35(36): 543557.
［7］ WEN D, DING Y. Experimental investigation into the pool boiling heat transfer of aqueous based γalumina nanofluids ［J］. Journal of Nanoparticle Research, 2005, 7(2): 265274.
［8］ JANG S P, CHOI S U S. Cooling performance of a microchannel heat sink with nanofluids ［J］. Applied Thermal Engineering, 2006, 26(17/18): 24572463.
［9］ LEE J, MUDAWAR I. Assessment of the effectiveness of nanofluids for singlephase and twophase heat transfer in microchannels ［J］. Heat and Mass Transfer, 2007, 50(3/4): 452463.
［10］ MA H B, WILSON C, BORGMEYER B, et al. Effect of nanofluid on the heat transport capability in an oscillating heat pipe ［J］. Applied Physics Letters, 2006, 88 (14): 11611163.
［11］ CHOI S U S, YU W, HULL J R, et al. Nanofluids for vehicle thermal management ［C］∥ Vehicle Thermal Management Systems Conference and Exhibition. Nashville: SAE, 2001.
[1] 李冠球, 李蔚, 张政江, 张巍, 徐志明. 基于冯-卡门类比建立螺纹管内颗粒污垢模型[J]. J4, 2010, 44(3): 494-498.