Please wait a minute...
浙江大学学报(工学版)
机械工程     
基于圆盘缝隙阻尼器的中心通流静压推力轴承
李林, 顾临怡, 罗高生
1.浙江大学 流体动力与机电系统国家重点实验室,浙江 杭州 310027
Hydrostatic thrust bearing with central flow path based on circular flat slit fed restrictor
LI Lin, GU Lin-yi, LUO Gao-sheng
1. State Key Laboratory of Fluid Power Transmission and Control, Zhejiang University, Hangzhou 310027, China
 全文: PDF(988 KB)  
摘要:

针对轴向柱塞马达变量阀配流机构的结构特点,提出圆盘缝隙前置阻尼中心通流式流体静压推力轴承的原理和结构.计算承载能力和油膜刚度,分析轴承密封带与圆盘缝隙前置阻尼平面的高度差对静压推力轴承特性的影响,并与细长孔前置阻尼流体静压推力轴承的承载能力和油膜刚度进行对比.结果表明,圆盘缝隙前置阻尼流体静压推力轴承的油膜绝对刚度较大,是油膜厚度的单调递减函数,油膜厚度越小刚度越大,承载能力稳定,负载适应能力较强;细长孔前置阻尼流体静压推力轴承在设计油膜厚度附近刚度最大,当油膜厚度改变时刚度减小.对高度差5和10 μm的2种样机进行对比试验,试验结果表明,2种轴承均可在压力0~12 MPa,当转速为0~1 000 r/min时正常工作,泄漏和摩擦都很小.当流体压力变化时,高度差为5 μm的轴承的泄漏量和摩擦扭矩相对较稳定.

关键词: 圆盘缝隙阻尼器流体静压推力轴承高转速旋转端面密封反馈液阻    
Abstract:

 Present the working principle and structure of a hydrostatic thrust bearing with a circular flat slit fed restrictor,which was designed for variable displacement seat valve distributor of a hydraulic motor. Calculated its bearing capacity and oil film stiffness, analyzed the influence of the height difference between the bearing surface and its circular flat slit fed restrictor on bearing characteristics, compared the circular flat slit fed restrictor hydrostatic thrust bearing with capillary fed restrictor bearing. The results show that the oil film stiffness of the hydrostatic thrust bearing presented in this paper decreases monotone with the thickness of the oil film, and the bearing capacity was more stable than capillary fed restrictor bearing, while the capillary fed restrictor bearing had its best oil film stiffness at its rated working oil film thickness. Hydrostatic thrust bearings with height difference 5 μm and 10 μm were tested,the test results showed that both bearings work with less leakage and friction torque compared with traditional valve plate under 12 MPa and 1000 rpm. The bearing with 5μm height difference is more stable.

Key words: high shaft speed    circular flat slit restrictor    hydrostatic thrust bearing    rotary face seal    fed restrictor
出版日期: 2015-02-17
:  TH 137.51  
通讯作者: 顾临怡,男,教授     E-mail: lygu@zju.edu.cn
作者简介: 李林(1981—),男,博士生,从事液压元件及系统研究.E-mail: sharin@zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  
顾临怡
罗高生
李林

引用本文:

李林, 顾临怡, 罗高生. 基于圆盘缝隙阻尼器的中心通流静压推力轴承[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2015.02.013.

LI Lin, GU Lin-yi, LUO Gao-sheng. Hydrostatic thrust bearing with central flow path based on circular flat slit fed restrictor. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2015.02.013.

链接本文:

http://www.zjujournals.com/xueshu/eng/CN/10.3785/j.issn.1008-973X.2015.02.013        http://www.zjujournals.com/xueshu/eng/CN/Y2015/V49/I2/282

[1] 路甬祥,液压气动技术手册[M].北京: 机械工业版社, 2007: 5-17.
[2] 许耀明, 油膜理论与液压泵和马达的摩擦副设计[M].北京:机械工业出版社,1987:13.
[3] LI Lin, GU Lin-yi, LUO Gao-sheng, etc. Simulation research on the variable displacement hydraulic motor with variable effective piston stroke for hydraulic propulsion system [C]∥ Oceans 2012 MTS/IEEE: VA. Virginia Beach, US: \[s.n.\], 2012: 14-19.
[4] BRIAN ROWE W. Hydrostatic, aerostatic, and hybrid bearing design [M]. London, UK: Elsevier Inc. 2012: 138-140.
[5] 陈燕生, 液体流体静压推力轴承原理和设计[M].北京: 国防工业出版社, 1980: 39-44.
[6] 王勇勤, 刘志芳, 严兴春,等.毛细管节流静压油膜轴承动态特性分析[J]. 重庆大学学报, 2011, 34(3): 25-31.
WANG Yong-Qin, LIU Zhi-Fang, YAN Xin-chun, et al. Analysis on dynamic performance of hydrostatic oil film bearing throttled by capillary [J]. Journal of Chongqing University, 2011, 34(3): 25-31.
[7] 朱世强, 林建亚. 巨型转动构件高精度静平衡方法的研究[J]. 机械工程学报, 2001, 37(4), 12-16.
ZHU Shi-qiang, LIN Jian-ya. Study on high accuracy balancing methods for huge rotor [J]. Chinese Journal of Mechanical Engineering, 2001, 37(4): 12-16.
[8] 张有华. 高压机械密封的设计与应用[J]. 流体机械, 2005, 33(2): 58.
ZHANG You-hua,. Design and application of mechanical seal for high pressure [J]. Fluid Machinery, 2005, 33(2): 58.
[1] 欧阳小平,薛志全,彭超,周清和,杨华勇. 航空作动器的VL密封特性分析[J]. 浙江大学学报(工学版), 2015, 49(9): 1755-1761.
[2] 李林,陈家旺,顾临怡,王峰. 轴向柱塞泵/马达变量阀配流机构[J]. J4, 2014, 48(1): 29-34.
[3] 翟江,周华. 海水淡化轴向柱塞泵静压支承滑靴副的
流固耦合分析
[J]. J4, 2011, 45(11): 1889-1894.