Please wait a minute...
J4  2013, Vol. 47 Issue (11): 1958-1963    DOI: 10.3785/j.issn.1008-973X.2013.11.011
能源工程     
平板式微藻光反应器的流场优化及闪光效应
程军,庄良,黄云, 孙晶,周俊虎,岑可法
浙江大学 能源清洁利用国家重点实验室,浙江 杭州 310027
Flow field optimization and flashing light effect of flat plate photobioreactor for microalgae growth
CHENG Jun, ZHUANG Liang, HUANG Yun, SUN Jing, ZHOU Jun-hu, CEN Ke-fa
State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027,  China
 全文: PDF 
摘要:

针对微藻闪光效应的特点,开发一种内置交叉导流横向隔板的平板气升环流式微藻光反应器.研究藻液中光衰减规律和通气流量对微藻生长的影响,通过流场数值模拟剖析闪光效应特点,实验对比不同反应器的生物质产量.得到微拟球藻液的光衰减公式,每升藻液的最佳通气流量为05 L·min-1.反应器增加交叉导流横向隔板后,形成一个顺时针和逆时针旋转的交替更迭的大涡流动,加强气液混合和物质传递,在水平光程方向上藻液速度提高到15~22倍,藻液光暗循环周期显著降低到无横向隔板时的1/19.结果表明,快速闪光效应能够明显促进微藻光合生长,最终使微藻生物质产量提高了25%.

关键词: 光反应器微藻气升闪光效应生物质    
Abstract:

According to the properties of the flashing light effect, a novel flat plate airlift loop photobioreactor with inner cross-diversion transverse baffles was developed for microalgae growth. The light attenuation characteristics in microalgae medium and airlift flow effects on microalgae growth were studied. The flashing light effect was analyzed through numerical simulation of flow field and microalgae biomass yields in two photobioreactors were compared by experiments. The light attenuation formula of Nannochloropsis sp. medium was calculated and optimal airlift flow rate of 05 L·min-1 per liter was obtained. When cross-diversion transverses baffles were placed in a flat plate airlift loop photobioreactor, a turbulent flow field with many large eddies that clockwise vortices alternated with anticlockwise vortices was formed in the airlift procedure, which improved gas-liquid mixing and nutrients mass transfer. The horizontal flow velocity of microalgae medium increased to 15~22 times and light-dark cycle period markedly reduced to 1/19 compared to those in the photobioreactor without cross-diversion transverse baffles. The results show that the high-frequence flashing light effect improved microalgae growth and increased biomass yield by 25%.

Key words: photobioreactor    microalgae    airlift    flashing light effect    biomass
出版日期: 2013-12-05
:  TK 6  
基金资助:

国家自然科学基金资助项目(51176163);国家“863” 高技术研究发展计划资助项目(2012AA050101);浙江省重点基金资助项目(Z1090532);国家“十一五”科技支撑计划资助项目(2011BAD14B02);国际科技合作计划资助项目(2010DFA72730).

作者简介: 程军(1974-),男,教授,博导,从事可再生能源和CO2减排研究.E-mail:juncheng@zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

程军,庄良,黄云, 孙晶,周俊虎,岑可法. 平板式微藻光反应器的流场优化及闪光效应[J]. J4, 2013, 47(11): 1958-1963.

CHENG Jun, ZHUANG Liang, HUANG Yun, SUN Jing, ZHOU Jun-hu, CEN Ke-fa. Flow field optimization and flashing light effect of flat plate photobioreactor for microalgae growth. J4, 2013, 47(11): 1958-1963.

链接本文:

http://www.zjujournals.com/xueshu/eng/CN/10.3785/j.issn.1008-973X.2013.11.011        http://www.zjujournals.com/xueshu/eng/CN/Y2013/V47/I11/1958

[1] SPOLAORE P, JOANNIS-CASSAN C, DURAN E, et al. Commercial applications of microalgae [J]. Journal of Bioscience and Bioengineering, 2006, 101(2): 87-96.
[2] POSTEN C. Design principles of photobioreactors for cultivation of microalgae [J]. Engineering in Life Sciences, 2009, 3: 165-177.
[3] RICHMOND A. Principles for attaining maximal microalgal productivity in photobioreactors: an overview [J]. Hydrobiologia, 2004, 512: 33-37.
[4] KONDO T, WAKAYAMA T, MIYAKE J. Efficient hydrogen production using a multi-layered photobioreactor and a photosynthetic bacterium mutant with reduced pigment [J]. International Journal of Hydrogen Energy, 2006, 31(11): 1522-1526.
[5] POLLE J, KANAKAGIRI S, JIN E, et al. Truncated chlorophyll antenna size of the photosystems: a practical method to improve microalgal productivity and hydrogen production in mass culture \
[J\]. International Journal of Hydrogen Energy, 2002, 27(11/12): 1257-1264.
[6] ORLANDO J, ASHER K, EMERSON A, et al. Comparative energy life cycle analyses of microalgal biomass production in open ponds and photobioreactors [J]. Bioresource Technology, 2010, 101: 1406-1413.
[7] JANSSEN M, JANSSEN M, WINTER M, et al. Efficiency of light utilization of Chlamydomonas reinhardtii under medium-duration light/dark cycles [J]. Journal of Biotechnology, 2000b, 78: 123-137.
[8] GHOSAL S, TOGERS M, WRAY A. The turbulent life of phytoplankton [C]∥Center for Turbulence Research Proceedings of the Summer Program. [S. l.]: [s. n.], 2000: 31-46.
[9] GROBBELAAR J. Turbulence in mass algal cultures and the role of light/dark fluctuations [J]. Journal of Applied Phycology, 1994, 6: 331-335.
[10] EDWARDS N, BEETON S, BULL A, et al. A novel device for the assessment of shear effects on suspended microbial cultures [J]. Applied Microbiology and Biotechnology, 1989, 30: 190-195.
[11] PERNER I, POSTEN C, BRONESKE J. CFD optimization of a plate photobioreactor used for cultivation of microalgae [J]. Engineering in Life Sciences, 2003, 16: 287-291.
[12] PRUVOST J, POTTIER L, LEGRAND J. Numerical investigation of hydrodynamic and mixing conditions in a torus photobioreactor [J]. Chemical Engineering Science, 2006, 61: 4476-4489.
[13] YU G, LI Y, SHEN G, et al. A novel method using CFD to optimize the inner structure parameters of flat photobioreactors [J]. Journal of Applied Phycology, 2009, 21: 719-727.
[14] 林晨, 李元广, 王伟良, 等. 一种新型多节隔板平板式光生物反应器的数值和实验研究 [J].高校化学工程学报, 2009, 23(2): 263-269.
LIN Chen, LI Yuan-guang, WANG Wei-liang, et al. Numerical and experimental investigation of a novel flat photobioreactor with multistage separator [J].Journal of Chemical Engineering of Chinese Universities, 2009, 23(2): 263-269.
[15] 李昱喆, 齐祥明, 刘天中, 等. 带波纹隔板的平板式光生物反应器流动特性 [J].过程工程学报, 2009, 10(5): 849-855.
LI Yu-zhe, QI Xiang-ming, LIU Tian-zhong, et al. Investigation on hydrodynamic behaviors in a wave-baffled panel photobioreactor [J]. The Chinese Journal of Process Engineering, 2009, 10(5): 849-855.
[16] 黄适, 吴双秀, 徐健. 微拟球藻培养中共生关系的初步研究 [J].安徽农业科学, 2011, 29(23): 14246-14249.
HUANG Shi, WU Shuang-xiu, XU Jian. Study on symbiotic association in Nannochloropsis culture [J]. Journal of Anhui Agriculture Science, 2011, 29(23): 14246-14249.
[17] BARBARA B, KELLY A. Investigation of the light dynamics and their impact on algal growth rate in a hydraulically integrated serial turbidostat algal reactor (HISTAR) [J]. Aquacultural Engineering, 2006, 35: 122-134.
[18] CORNET J, DUSSAP C, GROS J, et al. A simplified monodimensional approach for modeling coupling between radiant light transfer and growth kinetics in photobioreactors [J]. Chemical Engineering Science, 1995, 50(9): 1489-1500.
[19] MERCHUK J. Shear effects on suspended cells [J]. Advanced Biochemical Engineering, 1991, 44: 65-95.
[20] 胡晗华, 高坤山. CO2对微拟球藻(Nannochloropsis sp.)利用有机碳和光合作用的影响 [J]. 植物生理学通讯, 2006, 42(4): 633-637.
HU Han-hua, GAO Kun-shan. Effects of CO2 on the organic carbon utilization and photosynthesis of Nannochloropsis sp. [J]. Plant Physiology Communications, 2006, 42(4): 633-637.
[21] GILBERT J, RAY S, DAS D. Hydrogen production using Rhodobacter sphaeroides in a flat panel rocking photobioreactor [J]. International Journal of Hydrogen Energy, 2011, 36: 3434-3441.

[1] 罗龙皂, 邵瑜, 田光明. 基于微藻培养的养猪废水氨氮吹脱预处理[J]. 浙江大学学报(工学版), 2017, 51(10): 2055-2060.
[2] 龚彬, 余春江, 王准, 骆仲泱. 生物质炉排锅炉不同受热面沉积特性[J]. 浙江大学学报(工学版), 2015, 49(8): 1578-1584.
[3] 麻剑, 谢阳, 罗麒元, 许沧粟. 精制生物油和柴油混合燃料的柴油机性能[J]. 浙江大学学报(工学版), 2015, 49(4): 632-637.
[4] 陈超, 周劲松, 项阳阳, 顾珊, 骆仲泱. 生物质高温气流床分级气化特性[J]. 浙江大学学报(工学版), 2015, 49(4): 626-631.
[5] 陈冠益,孔韡,徐莹,李婉晴,马隆龙,颜蓓蓓,陈鸿. 生物质化学制氢技术研究进展[J]. 浙江大学学报(工学版), 2014, 48(7): 1318-1328.
[6] 余春江,王准,龚彬,骆仲泱. 生物质锅炉钢材在氯化钾接触条件下腐蚀特性[J]. 浙江大学学报(工学版), 2014, 48(11): 2046-2052.
[7] 朱颖颖, 王树荣, 葛晓岚, 李信宝, 周劲松, 骆仲泱. 生物质基合成气合成甲醇的热力学模拟研究[J]. J4, 2011, 45(2): 341-347.
[8] 沈雪亮, 范永仙, 汪钊. 外循环气升式生物反应器中酯酶生产及应用[J]. J4, 2010, 44(2): 320-325.
[9] 周劲松 赵辉 曹小伟 骆仲泱 岑可法. 生物质气流床气化特性及残炭特性的研究[J]. J4, 2009, 43(1): 128-134.
[10] 王树荣 郑赟 骆仲泱 施正伦 岑可法. 生物质组分热裂解动力学研究[J]. J4, 2007, 41(4): 585-588.
[11] 周劲松 刘亚军 骆仲泱 岑可法. 酸性、碱性催化剂对生物质焦油催化裂解影响分析[J]. J4, 2005, 39(7): 1047-1051.
[12] 卢刚 郑平. 气升式内循环反应器短程硝化控制策略的研究[J]. J4, 2005, 39(4): 542-546.
[13] 文丽华 王树荣 骆仲泱 王琦 施海云 方梦祥 岑可法. 生物质的多组分热裂解动力学模型[J]. J4, 2005, 39(2): 247-252.