Please wait a minute...
浙江大学学报(工学版)
J4  2009, Vol. 43 Issue (8): 1469-1472    DOI: 10.3785/j.issn.1008-973X.2009.
动力与电气工程     
双振子自走型直线超声电机的研究
鹿存跃1,魏燕定1,郭吉丰1,胡金云2,黎金良1
(1.浙江大学 电气工程学院, 浙江 杭州 310027; 2.清华大学 物理系, 北京 100084)
Self-driving linear ultrasonic motor with double vibrators
LU Cun-yue1, WEI Yan-ding1, GUO Ji-feng1, HU Jin-yun2, LI Jin-liang1
1. College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China;
2. Department of Physics, Tsinghua University, Beijing 100084, China
 全文: PDF(832 KB)  
摘要：

设计了一种双振子自走型直线超声电机,电机的定子由2个同轴的对称布置的弯曲摇头型振子和中部带细颈的柔性振动块组成.2个振子的弯曲振动会激励出中间振动块的摇头振动,使驱动头上的质点产生椭圆运动轨迹,与导轨摩擦接触产生自走直线运动.测量得到定子上振动块的局部弯曲共振频率为20 792Hz,定子的弯曲共振频率约为40 420Hz.仿真发现,以振动块的局部弯曲共振模态作为工作模态能够得到更大的振幅.实验结果表明,在该模态频率下,电机可以提供较大的驱动速度,发热很少,较长时间工作仍旧稳定可靠,故被选作工作模态.在40 420Hz附近电机能够驱动,但是振子发热严重,不易稳定工作.当两相驱动信号的频率为20.8kHz、相位差为90°、驱动信号电压的峰峰值为138V时,电机的驱动速度达到598mm/s,电机的最大驱动力达到1.94N.
关键词： 直线超声电机;  压电陶瓷;  弯曲振动;  共振模态;  超声振动    
Abstract:

A self-driving linear ultrasonic motor with double vibrators was developed. The stator consists of two vibrators and a mass. The mass is in the middle of the stator. Each vibrator is symmetrically connected with one side of the mass by a slender shaft. The bending vibrations of two vibrators inspire a wobbling motion of the mass. Therefore, the locus of particles on the driving head is an ellipse. The friction force between the mass and the leader drives the motor moving itself. The measured local bending resonant frequency of the mass is about 20 792Hz, and that of the stator is about 40 420Hz. Emulation results showed that when the local bending resonant mode of the mass is used as working mode, the vibration amplitude of the mass is large. Experimental results showed that the driving speed of the motor is high and the motor can work stably with little temperature rise when the mass working in the local bending resonant mode. But when the  bending resonant mode of the stator is used as working mode, the temperature rise of the stator is high, therefore the motor cannot work stably. The characteristics of the prototype motor were measured experimentally. The maximum speed of the motor is about 598mm/s, and the maximum driving force is over 1-94N, when the phase difference of the applied two signals is 90° and the peak to peak driving voltage is 138 V at the frequency of 20-8kHz.
Key words: linear ultrasonic motor    piezoelectric ceramic    bending vibration    resonant mode    ultrasonic vibration
出版日期: 2009-09-01
:  TM 356  
基金资助:

国家自然科学基金资助项目（10874152）;浙江省自然科学基金资助项目（Y7080361）;中国科学院声场声信息国家重点实验室开放基金资助项目（200706）
作者简介: 鹿存跃（1973-），男，江苏徐州人，副教授，从事超声电机和压电驱动器研究.
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　
鹿存跃
魏燕定
郭吉丰
等

引用本文:

鹿存跃,魏燕定,郭吉丰,等. 双振子自走型直线超声电机的研究[J]. J4, 2009, 43(8): 1469-1472.

LU Cun-Ti, WEI Yan-Ding, GUO Ji-Feng, et al. Self-driving linear ultrasonic motor with double vibrators. J4, 2009, 43(8): 1469-1472.

链接本文:

http://www.zjujournals.com/xueshu/eng/CN/10.3785/j.issn.1008-973X.2009.    或    http://www.zjujournals.com/xueshu/eng/CN/Y2009/V43/I8/1469

[1] MORITA T. Miniature piezoelectric motors [J]. Sensors and Actuators, 2003, 103(3): 291300.
[2] UEHA S, TOMIKAWA Y, KOROSAWA M, et al. Ultrasonic motors: theory and application [M]. Oxford: Clarendon Press, 1993.
[3] 赵淳生. 超声电机技术与应用[M]. 北京:科学出版社, 2007.
[4] MANCEAU J F, BASTIEN F. Linear motor using a quasi-travelling wave in a rectangular plate [J]. Ultrasonics, 1996, 34(2-5): 257-260.
[5] ROH Y, LEE S, HAN W. Design and fabrication of a new traveling wave-type ultrasonic linear motor [J]. Sensors and Actuators, 2001, 94(3): 205-210.
[6] YUN C. A high power ultrasonic linear motor using a longitudinal and bending hybrid bolt-clamped Langevin type transducer [J]. Japanese Journal of Applied Physics, 2001, 40(5B): 3773-3776.
[7] TSAI M, LEE C, HWANG S. Dynamic modeling and analysis of a bimodal ultrasonic motor [J]. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 2003, 50(3): 199-203.
[8] KRUSAWA M, TAKAHASHI M, HIGUCHI T. Friction drive surface acoustic wave motor [J]. Ultrasonics, 1996, 34(2-5): 243-246.
[9] ROHA Y, KWON J. Development of a new standing wave type ultrasonic linear motor [J]. Sensors and Actuators, 2004, 112(2/3): 196-202.
[10] SNIKA V. Ultrasonic actuators for nanometre positioning [J]. Ultrasonics, 2000, 38(1): 20-25.
[11] KIM J, KIM J D, CHOI S. A hybrid inchworm linear motor [J]. Mechatronics, 2002, 12(4): 525-542.
[1] 林超, 陶友淘, 程凯, 俞松松, 刘垒. 微/纳传动平台的位移耦合分析[J]. J4, 2013, 47(4): 720-727.
[2] 林超, 俞松松, 程凯, 崔新辉, 陶友淘, 王静超. 微/纳米定位平台的动态特性分析与试验[J]. J4, 2012, 46(8): 1375-1381.
[3] 林超, 俞松松, 陶桂宝, 程凯, 陶友淘, 宿新红. 微/纳米定位平台的桥式机构静、动态优化设计[J]. J4, 2012, 46(6): 1067-1073.
[4] 陈海初 王宣银 张蕊华 谭冲 张阳. 压电陶瓷驱动精密流量阀的设计与建模[J]. J4, 2008, 42(11): 1936-1939.
[5] 陈海初 孙立宁 王宣银. 全方位精密微小型移动机器人的运动分析[J]. J4, 2006, 40(4): 577-580.