Please wait a minute...
浙江大学学报(工学版)
J4  2009, Vol. 43 Issue (8): 1428-1432    DOI: 10.3785/j.issn.1008-973X.2009.
光学仪器     
用Zernike自由曲面设计弯曲屏幕超薄投影系统
孙旭涛,郑臻荣,刘旭,顾培夫
(浙江大学 现代光学仪器国家重点实验室, 浙江 杭州 310027)
Design of ultra-thin projection system with curved screen based on
Zernike free-form surfaces
 SUN Xu-Chao, ZHENG Zhen-Rong, LIU Xu, GU Pei-fu
State Key Laboratory of Modern Optical Instrumentation, Zhejiang University, Hangzhou 310027, China
 全文: PDF(618 KB)  
摘要：

基于非球面离轴反射式投影系统,提出了采用Zernike自由曲面取代非球面进一步优化系统结构的设计方法,并利用Zernike多项式与Seidel像差之间的关系,优化系统的成像性能.设计采用一片Zernike自由曲面取代四片非球面系统中的一片非球面,使投影系统的厚度从24cm减为20cm,边缘视场的调制传递函数（MTF）在50lp/mm时由45％提高到57％,中心视场及0.7视场的MTF由60％提高到了70％,两系统畸变均小于3％,且由于采用柱面弯曲屏幕设计,场曲均在18mm以下.研究结果表明,应用Zernike自由曲面设计投影系统不仅可以提高光学系统的性能,而且可以实现更加超薄的系统结构.
关键词： 光学设计;  超薄投影系统;  Zernike多项式;  自由曲面;  弯曲屏幕    
Abstract:

Based on the aspheric off-axis reflection projection system, the Zernike free-form surface was adopted to replace the aspheric surface in order to further optimize the system structure. The relationship between Zernike polynomial and Seidel aberration was utilized to improve the system performance. One aspheric surface in four aspheric system was replaced by one Zernike free-form surface, thus the thickness of the projection system was reduced from 24 cm to 20 cm; the modulation transfer function (MTF) of ±1 field was improved from 45% to 57% at 50 lp/mm, and the MTFs of both center field and 0.7 field were improved from 60% to 70%; the distortions of both systems were less than 3%, and the field curvature was less than 18 mm because the screen was cylinder. The results show that the projection system with Zernike free-form surface can not only improve the performance of optical system but also realize more ultra-thin structures.
Key words: optical design    ultra-thin projection system    Zernike polynomials    free-form surface    curved screen
出版日期: 2009-09-01
:  O 439  
基金资助:

浙江省自然科学基金资助项目（R104096）
通讯作者: 郑臻荣，男，副教授.     E-mail: zzr@zju.edu.cn
作者简介: 孙旭涛（1981－），男，山东莱阳人，博士生，主要从事投影显示系统研究.
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　
孙旭涛
郑臻荣
刘旭
??

引用本文:

孙旭涛,郑臻荣,刘旭,等. 用Zernike自由曲面设计弯曲屏幕超薄投影系统[J]. J4, 2009, 43(8): 1428-1432.

SUN Xu-Chao, ZHENG Zhen-Rong, LIU Xu, et al. Design of ultra-thin projection system with curved screen based on
Zernike free-form surfaces. J4, 2009, 43(8): 1428-1432.

链接本文:

http://www.zjujournals.com/xueshu/eng/CN/10.3785/j.issn.1008-973X.2009.    或    http://www.zjujournals.com/xueshu/eng/CN/Y2009/V43/I8/1428

[1] SHIAMA S. Optical system of ultra-thin rear projector equipped with refractive reflective projection optics [C]∥ Society for Information Display. Boston: SID, 2002: 1250-1253.
[2] OGAWA J, AGATA K, SAKAMOTO M, et al. Super-short focus front projectior with aspheric mirror projection optical system [C]∥ Society for Information Display. Seattle: SID, 2004: 170-173.
[3] KUDAEV S, SCHREIBER P. Optimization of symmetrical free-shape non-imaging concentrators for LED light source applications [J]. SPIE, 2005, 5942: 901-910.
[4] TIMINGER A, MUSCHAWECK J, RIESA H. Designing tailored free-form surfaces for general illumination [J]. SPIE, 2003, 5186: 128-132.
[5] Li Y. Optical performance of extreme-ultraviolet lithography for 50nm generation [J]. Acta Optica Sinica, 2004, 20(7): 865-868.
[6] RIES H R, WINSTON R. Tailored edge-ray reflectors for illumination [J]. Journal of the Optical Society of America A, 1994, 11(4): 1260-1264.
[7] RIES H R. Tailoring freeform lenses for illumination [J]. SPIE, 2001, 4442: 43-50.
[8] NOLL R. Zernike polynomials and atmospheric turbulence [J]. Journal of the Optical Society of America, 1976, 66(3): 207-211.
[9] GUIRAO A, MANUEL R, ARTAL P. Optical aberrations of the human cornea as a function of age [J]. Journal of the Optical Society of America A, 2000, 17(10): 1697-1702.
[10] CONFORTI G. Zernike aberration coefficients from Seidel and higher-order power-series coefficients [J]. Optics Letters, 1983, 8(7): 407-408.
[11] BORN M, WOLF E. Principles of optics [M]. 6th ed. Oxford: Pergamon Press, 1993.
[12] TYSON R K. Conversion of Zernike aberration coefficients to Seidel and higher-order power-series aberration coefficients [J]. Optics Letters, 1982, 7(6): 262-264.
[1] 潘炜, 吴慧, 李铁瑞, 高博青. 基于曲面展开的自由曲面网格划分[J]. 浙江大学学报(工学版), 2016, 50(10): 1973-1979.
[2] 马腾, 赵兴忠, 高博青, 吴慧. 自由曲面形状和拓扑联合优化研究[J]. 浙江大学学报(工学版), 2015, 49(10): 1946-1951.
[3] 崔国勇, 崔昌禹, 涂桂刚. 自由曲面混凝土结构力学特性[J]. 浙江大学学报(工学版), 2015, 49(10): 1960-1966.
[4] 丁慧, 罗尧治. 自由形态网壳结构网格生成的等参线分割法[J]. 浙江大学学报(工学版), 2014, 48(10): 1795-1801.
[5] 王艳, 李海峰, 徐熙平. 双灯投影机方棒照明系统的设计[J]. J4, 2011, 45(2): 382-386.
[6] 卢科青, 王文, 陈子辰. 基于双测头组合的未知自由曲面自适应采样[J]. J4, 2010, 44(8): 1433-1440.
[7] 于谦, 沈亦兵, 杨甬英. 大视场高分辨率光学检查镜的设计和检测[J]. J4, 2010, 44(6): 1220-1224.
[8] 卢科青,王文,汪玮,陈子辰. 基于可变向测头的未知自由曲面数字化测量[J]. J4, 2010, 44(11): 2041-2049.
[9] 边柯柯, 王青, 李江雄, 等. 复杂自由曲面模型的局部协调设计技术[J]. J4, 2009, 43(6): 1118-1123.
[10] 寿建军 关富玲 王森 姜爱民. 螺栓装夹作用下空间光学摆镜变形研究[J]. J4, 2008, 42(4): 720-724.
[11] 郑臻荣 孙旭涛 缪盈盈 顾培夫 刘旭. 应用泽尼克多项式自由曲面的成像物镜设计[J]. J4, 2008, 42(12): 2202-2206.
[12] 丁毅 顾培夫 陆巍 郑臻荣. 利用微分方程数值解构造自由曲面反光器[J]. J4, 2007, 41(9): 1516-1518.
[13] 吴思源 周晓军 江健 杨辰龙. 超声检测中曲面重构和路径规划方法研究[J]. J4, 2006, 40(5): 763-767.
[14] 石岩 倪旭翔 王立强 陆祖康. 双激光生物芯片分析仪扫描物镜设计[J]. J4, 2005, 39(7): 1056-1059.