Please wait a minute...
浙江大学学报(工学版)
浙江大学学报(工学版)
机械工程     
抗式消声器二次噪声的研究
吴大转,陈一伟,苗天丞,许伟伟,王乐勤
浙江大学 化学工程与生物工程系,浙江 杭州 310027
Study on regeneration noise of reactive muffler
WU Da-zhuan,CHEN Yi-wei,MIAO Tian-cheng,XU Wei-wei,WANG Le-qin
Department of Chemical Engineering, Zhejiang University, Hangzhou 310027 , China
 全文: PDF(1865 KB)   HTML
摘要：

为了研究气体流经抗式消声器时产生的二次噪声的声压级及频谱特性,通过Fluent软件对气流二次噪声的声压级及其随流速的变化规律进行模拟预测,并搭建带有抗式消声器的排气管路装置及尾端声压测试装置对排气管口的噪声进行监测.结果显示：气体流经抗式消声器时产生的二次噪声在整个频域内普遍存在,且为宽频带噪声,其量值随着流速增加而增加,但其增加的幅度随着流速的增加逐渐减小；在流速逐渐增加的过程中,高频段的噪声增加量总是高于低频段的增加量；气流速度的大小对消声器消声量产生一定的影响,气流速度越大,产生的二次噪声越大,其消声量越小,当气流速度大于一定值时,抗式消声器的消声量显著下降.
Abstract:

In order to study the frequency spectrum characteristics of the noise produced by the gas flowing through the reactive muffler, the exhaust pipe with reactive muffler inside and the end pressure testing device were used to predict the regeneration sound pressure level and its variation by Fluent software. The result shows that the gas generates broadband noise when flows through the reactive muffler, and its value increases with the flow rate increases, but the increase rate decreases with the increase of flow rate. In the process of flow rate increasing, the increase quantity of high-frequency noise is always higher than that of the low-frequency noise. Gas flow rate has a certain influence on the noise elimination amounts of reactive muffler, the increase of gas flow rate creates higher regeneration noise, thus leading to decrease of the elimination amounts. When  the gas flow rate is greater than a certain value, the attenuation performance of reactive muffler decreases significantly.
出版日期: 2014-09-01
:  TH 411  
作者简介: 吴大转 （1977-）,男,教授,博导.主要从事流体机械和流体噪声理论与控制研究. E-mail:wudazhuan@zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

吴大转,陈一伟,苗天丞,许伟伟,王乐勤. 抗式消声器二次噪声的研究[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2014.09.017.

WU Da-zhuan,CHEN Yi-wei,MIAO Tian-cheng,XU Wei-wei,WANG Le-qin. Study on regeneration noise of reactive muffler. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2014.09.017.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2014.09.017    或    http://www.zjujournals.com/eng/CN/Y2014/V48/I9/1661

［1］邓兆祥, 赵海军, 赵世举,等.穿孔管消声单元气流再生噪声产生机理［J］. 内燃机学报, 2009, 27(5):452-457．
DENG Zhao-xiang,ZHAO Hai-jun,ZHAO Shi-ju,et al.Producing mechanism of flow noise generation from perforated duct muffler element［J］.Journal of internal Combustion Engine,2009,27(5):452-457．
［2］TORREGROSA A J, BROATCH A, CLIMENT H, et al. ANoteonthe strouhal number dependence of the relative importance of internal and external flow noise sources in IC Engine Ex-haust Systems［J］. Journal of Sound and Vibration, 2005,282: 1255-1263．
［3］JEBASINSKI R, LENG S, JESS M, et al. Investigations on whistle noise in automotive exhaust system mufflers［J］. SAE Technical Paper, 2005(5):2005-01-2361．
［4］何卓烈,郭自杰.通风空调系统中气流再生噪声的试验研究及其在消声计算中的应用［J］.西安交通大学学报,1987,21(2):67-77．
HE Zhuo-lie,GUO Zi-jie.Identification and control of noise regeneration heating ventilation and air conditioning system［J］.Journal of Xian Jiao Tong University,1987,21(2) :67-77．
［5］位佳,陆森林,王彬,等. 抗性消声器插入损失的有限元法的探讨［J］. 机械设计与制造, 2011(9):35-37．
WEI Jia,LU Sen-lin,WANG Bin et al.Discussion of finite element method on insertion IOSS of reactive muffler［J］.Mechanical Design and Manufacturing,2011(9):35-37．
［6］孟新. 简单扩张式消声器气流再生噪声的CFD数值分析［D］. 镇江：江苏大学, 2012．
MENG Xin.CFD numerical analysis of simple expansion type silencer air flow regeneration noise［D］.Zhenjiang:Jiangsu University, 2012．
［7］DENG Zhao-xiang, ZHAO Hai-jun, ZHAO Shi-ju, et al. Producing mechanism of flow noise generation from perforated duct muffler element［J］. Transactions of CSICE, 2009, 27(5): 452-457．
［8］刘丽萍,肖福明,陆辰,等.存在气流时消声器消声性能的试验研究［J］.内燃机工程,2001,22(1):54-57．
LIU Li-ping,XIAO Fu-ming,LU Cheng,et al.The experimental study on the sound elimination performance of mufflers with airflow［J］.Chinese Internal Combustion Engine Engineering,2001,22(1):54-57．
［9］马家义, 袁兆成. 消声器内部流场及其对消声性能影响［J］. 车用发动机, 2007 (5): 31-34．
MA Jia-yi,YUAN Zhao-cheng.The flow field inside the muffler and its influence on acoustic attenuation performance［J］.Vehicle Engine, 2007(5)：31-34．
［10］黄继雄. 用传递矩阵分析方法对消声器进行总体参数优化［J］. 武汉工学院学报, 1991, 13(3): 57-62．
HUANG Ji-xiong.Using the transfer matrix method for optimization of overall parameters of muffler ［J］.Journal of Wuhan University, 1991, 13(3): 57-62．
No related articles found!