Please wait a minute...
浙江大学学报(工学版)
浙江大学学报(工学版)
光学工程、工程力学     
一类初弯曲转子的裂纹-碰摩故障响应分析
杨丹1, 甘春标2, 杨世锡2, 王跃华2
1.浙江大学 力学系,浙江 杭州 310027；2.浙江大学 机械工程学系,浙江 杭州 310027
Analysis on response of a rotor with initial bend deformation under coupling fault of crack and rub-impact
YANG Dan1, GAN Chun-biao2, YANG Shi-xi2, WANG Yue-hua2
1. Department of Mechanics, Zhejiang University, Hangzhou 310027, China; 2. Department of Mechanical Engineering, Zhejiang University, Hangzhou 310027, China
 全文: PDF(2028 KB)   HTML
摘要：

摘要: 为了研究裂纹-碰摩耦合故障的一类初弯曲转子系统响应特性,在考虑转轴变形、非线性油膜力与碰摩力作用的基础上,结合由中性轴理论确定的裂纹开闭规律,建立该类故障转子的动力学方程,利用Poincaré截面和分岔图的变化分析初始弯曲程度与裂纹深度对系统振动响应特性的影响.结果表明：含初弯曲时系统振动响应在临界转速附近的混沌区域比无初弯曲时大,随着裂纹深度的增加,混沌区域逐渐缩小；初始弯曲的运动特性在浅裂纹情况下起主导作用,当裂纹深度较大时,系统振动响应随着初始弯曲程度的增大交替出现由周期演变为混沌状态的过程,混沌响应特性也可发生较大变化.
Abstract:

To investigate the vibration response of a rotor with initial bend deformation under coupling faults of crack and rub-impact, the dynamic model of the rotor was established based on the switching regularity of the crack from the neutral axis theory, where the nonlinear oil-film force and the rub-impact force were taken into account, and the effects of the depth of crack and the degree of initial bend deformation on the vibration response of the rotor were discussed by the Poincaré’s cross-section and the bifurcation diagrams. The results indicate that, the chaotic region near the critical speed of the rotor with initial bend deformation is wider than that without initial bend deformation, and the chaotic region will reduce gradually as the depth of crack increases. Moreover, the motion characteristics of initial bend deformation play a dominant role in the case of shallow cracks, however, if the crack is relatively deep, the periodic and chaotic states alternate with each other as the degree of the initial bend deformation increases, and the characteristic of the chaotic response may also vary from the degree of the initial bend deformation.
出版日期: 2014-08-01
:  TH 113.1  
基金资助:

国家自然科学基金资助项目（11172260,11072213, 51375434）；高等学校博士学科点专项科研基金资助项目（20110101110016）；浙江省科技计划项目基金资助项目（2013C31086）；中央高校基本科研业务费专项资金资助项目（2011QNA4001, 2013XZZX005）.
通讯作者: 甘春标，男，教授，博导     E-mail: cb_gan@zju.edu.cn
作者简介: 杨丹(1986—)，女，硕士生，从事机械动力学研究.E-mail: youhol@126.com
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

杨丹, 甘春标, 杨世锡, 王跃华. 一类初弯曲转子的裂纹-碰摩故障响应分析[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2014.08.020.

YANG Dan, GAN Chun-biao, YANG Shi-xi, WANG Yue-hua. Analysis on response of a rotor with initial bend deformation under coupling fault of crack and rub-impact. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2014.08.020.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2014.08.020    或    http://www.zjujournals.com/eng/CN/Y2014/V48/I8/1496

［1］ WAN Fang-yi, XU Qing-yu, LI Song-tao. Vibration analysis of cracked rotor sliding bearing system with rotor-stator rubbing by harmonic wavelet transform ［J］. Journal of Sound and Vibration, 2004, 271(3/5): 507-518.
［2］ PATEL T H, DARPE A K. Vibration response of a cracked rotor in presence of rotor-stator rub ［J］. Journal of Sound and Vibration, 2008, 317(3/5): 841-865.
［3］ 罗跃纲,闻邦椿.双跨转子-轴承系统裂纹-碰摩耦合故障的稳定［J］.机械工程学报,2008, 44(4): 123127, 132.
LUO Yue-gang, WEN Bang-chun. Stability of the two-span rotor-bearing system periodic with coupling faults of crack and rub-impact ［J］. Chinese Journal of Mechanical Engineering, 2008, 44(4): 123127, 132.
［4］ 罗跃纲.转子系统故障的若干非线性动力学问题及智能诊断研究［D］.沈阳:东北大学, 2002.
LUO Yue-gang. Study on some nonlinear dynamics problems of rotor system with faults and intelligent diagnosis method ［D］. Shenyang: Northeastern University, 2002.
［5］ 姚红良,李鹤,李小彭,等.裂纹碰摩耦合故障转子系统诊断分析［J］. 振动工程学报, 2006, 19(3): 307-312.
YAO Hong-liang, LI He, LI Xiao-peng, et al. Diagnoses of coupling fault of crack and rub-impact in rotor systems ［J］. Journal of Vibration Engineering, 2006, 19(3): 307-312.
［6］ ADILETTA G, GUIDO A R, ROSSI C. Chaotic motions of a rigid rotor in the short journal bearings ［J］. Nonlinear Dynamics, 1996, 10(3): 251-269.
［7］ 袁惠群,闻邦椿,李鸿光.非线性转子局部碰摩故障的分叉与混沌行为［J］.东北大学学报,2000, 2（6）： 610-613.
YUAN Hui-qun, WEN Bang-chun, LI Hong-guang. Bifurcation and chaos behavior of nonlinear local rubbing rotor ［J］. Journal of Northeastern University, 2000, 21(6): 610-613.
［8］ 袁惠群, 闻邦椿, 王德友. 非线性碰摩力对碰摩转子分叉与混沌行为的影响 ［J］. 应用力学学报, 2001, 4（18）： 16-20.
YUAN Hui-qun, WEN Bang-chun, WANG De-you. Effects of nonlinear rubbing and impact forces on the bifurcation and chaos behaviors of rub rotor ［J］. Chinese Journal of Applied Mechanics, 2001, 4(18): 16-20.
［9］ 闻邦椿,顾家柳,夏松波,等.高等转子动力学［M］. 北京: 机械工业出版社, 2000.
［10］ 杨丹,甘春标,杨世锡,等.含横向裂纹Jeffcott转子刚度及动力学特性研究［J］. 振动与冲击, 2012, 31(15): 121-126.
YANG Dan, GAN Chun-biao, YANG Shi-xi, et al Studies on stiffness and dynamical behavior of Jeffcott rotor with cross crack ［J］. Journal of Vibration and Shock, 2012, 31(15): 121126.
［11］ 李振平,罗跃纲,姚红良,等.具有裂纹-碰摩耦合故障转子-轴承系统的动力学研究［J］.应用力学学报, 2003, 3(20): 136-140.
LI Zheng-ping, LUO Yue-gang, YAO Hong-liang, et al. Dynamics of rotor-bearing system with coupling faults of crack and rub-impact ［J］. Chinese Journal of Applied Mechanics, 2003, 3(20): 136-140.
[1] 黄伟,王家序,徐涛,肖科,李俊阳,吴会超. 金属橡胶复合齿轮副振动特性分析及实验[J]. 浙江大学学报(工学版), 2016, 50(11): 2231-2238.
[2] 程卫东,赵德尊　. 用于滚动轴承转频估计的EMD软阈值降噪算法[J]. 浙江大学学报(工学版), 2016, 50(3): 428-436.
[3] 田红亮,余媛,张屹. 机床支撑地脚结合部法向粗糙接触建模[J]. 浙江大学学报(工学版), 2015, 49(11): 2111-2118.
[4] 王跃华,甘春标 ,杨世锡,雷华. 有界噪声激励下Hénon-Heiles系统响应的降噪分析[J]. J4, 2011, 45(11): 1895-1899.