Please wait a minute...
浙江大学学报(工学版)
J4  2013, Vol. 47 Issue (12): 2073-2079    DOI: 10.3785/j.issn.1008-973X.2013.12.001
电气工程     
应用于超宽输入范围的变拓扑LLC电路
廖政伟1, 张雪1, 尤伟1, 姚玮1,2, 吕征宇1
1. 浙江大学 电气工程学院,浙江 杭州 310027；2. 浙江水利水电学院 电气工程系,浙江 杭州 310018
Variable LLC circuit used in ultra-wide input voltage range
LIAO Zheng-wei1, ZHANG Xue1, YOU Wei1, YAO Wei1,2,LU Zheng-yu1
1.College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China; 2. Department of Electrical Engineering, Zhejiang University of Water Conservancy and Electric Power, Hangzhou 310018,China
 全文: PDF  HTML
摘要：

为了拓展新能源并网的输入电压范围，提出一种全桥LLC (FBLLC)和半桥LLC(HBLLC)相结合的变拓扑电路.当输入电压低，采用FBLLC模态;当输入电压高，采用HBLLC模态.通过由数字信号处理器（DSP）进行全数字控制，电路随着输入电压的变化在HBLLC和FBLLC之间切换.这种变拓扑电路完全不增加额外器件，单纯依靠软件控制，控制简单，在拓扑切换上采用一种新的控制策略来尽可能优化效率.与传统LLC对比，分析和实验表明，在相同条件下，变拓扑LLC使输入电压范围能够拓展１倍.通过一个最大和最小输入电压比为4的对比试验，分别采用变拓扑LLC和传统LLC，结果表明：采用变拓扑电路，其整体效率能提升约3%.该拓扑适合应用于超宽输入电压范围的场合，如风力、光伏发电等.
Abstract:

A novel variable LLC was presented on the purpose of expending the grid input voltage range in new energy. The variable LLC varies between full bridge LLC (FBLLC) and half bridge LLC (HBLLC) with the step of input voltage. The topology is FBLLC when the input voltage is low; the topology will change to HBLLC automatically by digital signal processor (DSP) controller while the input voltage is high. The circuit does not add any additional component and with simple software control. A new topology switching strategy was also presented to optimize efficiency. Analysis and experimental result showed that the input voltage was expended to twice to that of the traditional LLC. The two topologies (variable LLC and traditional LLC) used in the occasion that the maximum to minimum input voltage ratio is 4 respectively. Experimental result showed that the total efficiency increased by about 3% by using the variable topology. The topology is suitable for applications with ultra-wide input voltage range such as solar and wind energy.
出版日期: 2013-12-01
:  TM 46  
基金资助:

 国家自然科学基金资助项目（51177148）.
通讯作者: 吕征宇,男,博士,教授,博导.     E-mail: eeluzy@cee.zju.edu.cn
作者简介: 廖政伟（1985—）,男,硕士生.从事新能源小型风力并网研究和DC-DC拓扑研究.E-mail: eelzw@zju.edu.cn
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

廖政伟, 张雪, 尤伟, 姚玮, 吕征宇. 应用于超宽输入范围的变拓扑LLC电路[J]. J4, 2013, 47(12): 2073-2079.

LIAO Zheng-wei, ZHANG Xue, YOU Wei, YAO Wei,LU Zheng-yu. Variable LLC circuit used in ultra-wide input voltage range. J4, 2013, 47(12): 2073-2079.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2013.12.001    或    http://www.zjujournals.com/eng/CN/Y2013/V47/I12/2073

［1］ 刘邦银,梁超辉,段善旭.直流模块式建筑集成光伏系统的拓扑研究［J］.中国电机工程学报,2008,28(20): 99-104.

LIU Bang-yin, LIANG Chao-hui, DEAN Shan-xu. Research on Topology of DC-module-based building integrated photovoltaic system［J］. Proceedings of the Chinese Society for Electrical Engineering, 2008,28(20): 99-104.

［2］ 张兴,曹仁贤,张崇巍，等.太阳能光伏并网发电及其逆变控制［M］.北京:机械工业出版社,2011.

［3］ YU F, XU D H, ZHANG Y J, et al. Design of high power density llc resonant converter with extra wide input range［C］∥ IEEE APEC. Anaheim: IEEE, 2007: 976-981.

［4］ OUYANG Z W, ZHANG Z, OLE C T, et al. Planar integrated magnetics design in wide input range DC-DC converter for fuel cell application［C］∥ IEEE ECCE. Atlanta: IEEE, 2010: 4611-4618 .

［5］ HAMAMURA S, NINOMIYA T, YAMAMOTO M, et al. Combined PWM and PFM control for universal line voltage of a piezoelectric transformer off-line converter ［J］. IEEE Transactions on Power Electronics, 2003, 18(1): 270-277.

［6］ CHEN W, RONG P, LU Z Y. A novel 200-800 Vdc ultra-wide range input Dc-dc converter with optimum polymorphic Topologies［C］∥ IEEE APEC. Washington DC: IEEE, 2009: 51-57.

［7］ ILKKA L, PONTUS M, THOMAS S. Methods of improving efficiency in wide input range boost converters at low input voltages［C］∥IEEE INTLEC. Phoenix: IEEE, 2000: 424-431.

［8］ YANG B, XU P, LEE FRED. Range winding for wide input range front end DC/DC converter［C］∥ IEEE APEC. Anaheim: IEEE, 2001: 476479.

［9］ CHEN W, HONG X Y, WANG S R, et al. High efficiency soft-switched step-up DC-DC converter with hybrid mode LLC+C resonant tank［C］∥IEEE APEC. Palm Springs: IEEE, 2010: 1358-1364.

［10］ YANG B, LEE FRED, ZHANG J F, et al. LLC resonant converter for front end DC/DC conversion［C］ ∥ IEEE APEC. Dallas: IEEE, 2002: 1108-1112.

［11］ 马皓,祁丰.一种改进的LLC变换器谐振网络参数设计方法［J］.中国电机工程学报,2008,28(33):611.

MA Hao, QI Feng. An improved design method for resonant tank parameters of LLC resonant converter［J］.Proceedings of the Proceedings of the Chinese Society for Electrical Engineering, 2008, 28(33): 6-11.

［12］ JUNG JEE-HOON, KWON, JOONG-GI. Theoretical analysis and optimal design of LLC resonant converter［C］∥ IEEE EPE.Aalborg: IEEE, 2007: 110.

［13］ 顾亦磊. 集成模块电源拓扑标准化的研究［D］. 杭州：浙江大学,2008.

GU Yi-lei. Research of topology standardization for integrated power module［D］. Hangzhou: Zhejiang University, 2008.

［14］ 陈威. DC-DC变流器的柔性变拓扑研究［D］. 杭州：浙江大学,2009.

CHEN Wei. Research on flexible topology of DC-DC converters［D］. Hangzhou: Zhejiang University, 2009.
[1] 王仕韬, 张达敏, 吕征宇, 张德华. 具有快速电流动态响应的晶闸管整流控制器[J]. J4, 2012, 46(2): 189-193.
[2] 顾亦磊, 陈威, 吕征宇. 柔性变流器及其应用[J]. J4, 2010, 44(3): 521-527.