Please wait a minute...
J4  2012, Vol. 46 Issue (7): 1238-1242    DOI: 10.3785/j.issn.1008-973X.2012.07.013
机械与能源工程     
危险废物焚烧炉烟气中二恶英气固相分配
姬亚,陆胜勇,林晓青,李晓东,严建华
浙江大学 能源清洁利用国家重点实验室,浙江 杭州 310027
Gas/particle partitioning of PCDD/Fs in flue gas of
hazardous waste incinerator
JI Ya, LU Sheng-yong, LIN Xiao-qing, LI Xiao-dong, YAN Jian-hua
State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China
 全文: PDF  HTML
摘要:

研究某危险废物焚烧炉烟气中二恶英气固相分配特征.结果表明,布袋除尘器入口烟气中二恶英气固相分配如下:气相二恶英的质量分数平均为62%,固相为38%;气相的毒性当量质量分数平均为76%,固相为24%.各异构体气相质量分数(即每个异构体气相部分质量浓度占该异构体气、固相总质量浓度的百分比)随氯代数的增加而降低,即高氯代异构体更多地附着于飞灰上,低氯代异构体则更多地分布于气相中;气相质量分数的变化趋势基本与蒸汽压相符,表明蒸汽压是决定焚烧烟气中二恶英各异构体气固相分配的主要因素之一.

Abstract:

The partitioning of polychlorinated dibenzo-p-dioxins and polychlorinated dibenzofurans (PCDD/Fs) between gas and solid phase in the flue gas of a hazardous waste incinerator was analyzed. Results show that, gas/particle partitioning of PCDD/Fs at the inlet of baghouse filter is as follows: gas/particle value is 62/38 according to the mass fraction, while it is 76/24 according to the I-TEQ concentration value. The fraction of gas phase PCDD/F congeners decreases with rising chlorination, i.e. highly chlorinated congeners have higher tendencies to attach to the fly ash, while lowly chlorinated congeners occupy a larger fraction of the gas phase. The fractions of gas phase congeners are roughly but not accurately in line with the vapor pressures, which indicates that vapor pressure is one of the main factors to determine the gas/particle partitioning of PCDD/F congeners in flue gas.

出版日期: 2012-07-01
:  X 705  
基金资助:

国家“973”重点基础研究发展规划资助项目(2011CB201500);国家“十一五”科技支撑计划资助项目(2007BAC27B04).

通讯作者: 陆胜勇,男,副教授.     E-mail: lushy@zju.edu.cn
作者简介: 姬亚(1988-), 男, 硕士生, 从事可燃固体废弃物焚烧及污染控制技术的研究. E-mail: jiya@zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

姬亚,陆胜勇,林晓青,李晓东,严建华. 危险废物焚烧炉烟气中二恶英气固相分配[J]. J4, 2012, 46(7): 1238-1242.

JI Ya, LU Sheng-yong, LIN Xiao-qing, LI Xiao-dong, YAN Jian-hua. Gas/particle partitioning of PCDD/Fs in flue gas of
hazardous waste incinerator. J4, 2012, 46(7): 1238-1242.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2012.07.013        http://www.zjujournals.com/eng/CN/Y2012/V46/I7/1238

[1] MCKAY G. Dioxin characterization, formation and minimisation during municipal solid waste (MSW) incineration: review [J]. Chemical Engineering Journal, 2002, 86: 343-368.
[2] STANMORE B R. The formation of dioxins in combustion systems [J]. Combustion and Flame, 2004, 136: 398-427.
[3] BUEKENS A, HUANG H. Comparative evaluation of techniques for controlling the formation and emission of chlorinated dioxins/furans in municipal waste incineration [J]. Journal of Hazardous Materials, 1998, 62: 1-33.
[4] CHI K H, CHANG S H, HUANG C H, et al. Partitioning and removal of dioxinlike congeners in flue gases treated with activated carbon adsorption [J]. Chemosphere, 2006, 64: 1489-1498.
[5] CHI K H, CHANG M B, CHANG S H. Evaluation of PCDD/F partitioning between vapor and solid phases in MWI flue gases with temperature variation [J]. Journal of Hazardous Materials, 2006, B138: 620-627.
[6] CHI K H, CHANG M B. Evaluation of PCDD/F congener partition in vapor/solid phases of waste incinerator flue gases [J]. Environmental Science and Technology, 2005, 39: 8023-8031.
[7] CHI K H, CHANG M B, CHANGCHIEN G P, et al. Characteristics of PCDD/F congener distributions in gas/particulate phases and emissions from two municipal solid waste incinerators in Taiwan [J]. Science of the Total Environment, 2005, 347: 148-162.
[8] CHEN T, GU Y L, YAN J H, et al. Polychlorinated dibenzopdioxins and dibenzofurans in flue gas emissions from municipal solid waste incinerators in China [J]. Journal of Zhejiang University: Science A, 2008, 9(9): 1296-1303.
[9] YAN J H, PENG Z, LU S Y, et al. Removal of PCDDs/Fs from municipal solid waste incineration by entrainedflow adsorption technology [J]. Journal of Zhejiang University: Science A, 2006, 7(11): 1896-1903.
[10] 严密, 李晓东, 陈彤, 等. 垃圾焚烧炉烟气中二恶英指示物研究 [J]. 燃烧科学与技术, 2010, 16(3): 257-261.
YAN Mi, LI Xiaodong, CHEN Tong, et al. Investigation of PCDD/Fs indicators in flue gas from waste incinerators [J]. Journal of Combustion Science and Technology, 2010, 16(3): 257-261.
[11] 高洪才, 倪余文, 张海军, 等. 不同垃圾焚烧设备中二噁英的排放特征和ITEQ指示物的研究 [J]. 环境科学, 2009, 30(5): 1545-1550.
GAO Hongcai, NI Yuwen, ZHANG Haijun, et al. PCDD/F emission characteristics in different waste incineration facilities and evaluation of 23478PeCDF as ITEQ indicator of PCDD/F in flue gases [J]. Environmental Science, 2009, 30(5): 1545-1550.
[12] 徐梦侠. 城市生活垃圾焚烧厂二恶英排放的环境影响研究 [D]. 杭州: 浙江大学, 2009: 51.
XU Mengxia. Environmental impact study on PCDD/F emissions from the municipal solid waste incineration plant [D]. Hangzhou: Zhejiang University, 2009: 51.
[13] RORDORF B F. Prediction of vapor pressures, boiling points and enthalpies of fusion for twentynine halogenated dibenzopdioxins and fiftyfive dibenzofurans by a vapor pressure correlation method [J]. Chemosphere, 1989, 18: 783-788.
[14] MADER B T, PANKOW J F. Vapor pressures of the polychlorinated dibenzodioxins (PCDDs) and the polychlorinated dibenzofurans (PCDFs) [J]. Atmospheric Environment, 2003, 37: 3103-3114.

[1] 符成龙,麻红磊,池涌,严建华,倪明江. 热水解处理制革污泥过程中总Cr的转移与稳定性研究[J]. J4, 2013, 47(9): 1631-1636.
[2] 谢浩辉,麻红磊,池涌,马增益. 污泥结合水测量方法和水分分布特性[J]. J4, 2012, 46(3): 503-508.
[3] 翁焕新, 章金骏, 曹彦圣, 马学文. 污泥陶粒的性能特征与烧制工艺[J]. J4, 2011, 45(10): 1877-1883.
[4] 王勤, 严建华, 潘新潮, 池涌, 高飞. 利用热等离子体熔融垃圾焚烧飞灰[J]. J4, 2011, 45(1): 141-145.
[5] 蒋旭光, 李春雨, 池涌, 俞恺, 傅娟娟. 医疗废物焚烧过程中无机溴的迁移特性研究[J]. J4, 2010, 44(9): 1787-1792.
[6] 马学文, 翁焕新. 温度与颗粒大小对污泥干燥特性的影响[J]. J4, 2009, 43(09): 1661-1667.