Please wait a minute...
浙江大学学报(工学版)
J4  2009, Vol. 43 Issue (8): 1458-1462    DOI: 10.3785/j.issn.1008-973X.2009.
动力与电气工程     
热声发动机驱动的脉管制冷机模拟及实验研究
李卓裴,邱利民,刘国军,王波,胡进勤
(浙江大学 制冷与低温研究所, 浙江 杭州 310027)
Simulation and experimental study of pulse tube cooler driven by thermoacoustic engine
 LI Zhuo-Fei, QIU Li-Min, LIU Guo-Jun, WANG Bo, HU Jin-qin
Institute of Refrigeration and Cryogenics, Zhejiang University, Hangzhou 310027, China
 全文: PDF(777 KB)   HTML
摘要：

基于回热器计算软件REGEN3.2,通过数值模拟分别研究了热声发动机的频率、输出压比、充气压力以及脉管制冷机的回热器长度对热声驱动的脉管制冷机制冷性能的影响,并预测了该台脉管制冷机的最低制冷温度为45K.实验研究了不同工质、热声发动机输出压比、声功输出装置以及脉管制冷机回热器长度对脉管制冷机性能的影响.实验结果表明,热声驱动的脉管制冷机的优化方向为提高热声发动机的输出压比、降低频率以及适当提高充气压力,这与数值模拟结果吻合较好.实验采用氮气-氦气双工质并以亥姆霍兹共鸣器作为声功输出装置和声压放大器,行波型热声发动机驱动的单级斯特林型脉管制冷机获得了65K的最低制冷温度.
Abstract:

The influences of frequency, pressure ratio, charging pressure and regenerator length  on the refrigeration performance of the pulse tube cooler driven by thermoacoustic engine were numerically simulated based on the regenerator simulation software known as REGEN3-2. The lowest no-load temperature of the pulse tube cooler was expected to be 45 K according to the simulation. The effects of working fluid, pressure ratio, acoustic power output device, and regenerator length were investigated experimentally. Experimental results show that the performance of the pulse tube cooler driven by a thermoacoustic engine can be improved significantly by increasing the pressure ratio, decreasing the frequency and properly increasing the charging pressure, which agrees well with the simulation. A single stage Stirling-type pulse tube cooler, with helium as the working fluid, driven by a traveling wave thermoacoustic engine with nitrogen as the working fluid and with a Helmholtz resonator as both acoustic power output device and acoustic pressure amplifier, obtained a lowest no-load temperature of 65 K.
出版日期: 2009-09-28
:  TB 651  
基金资助:

教育部新世纪优秀人才资助计划（NCET-06-0521）|教育部博士点基金资助项目（20060335120）
通讯作者: 邱利民，男，教授，博导.     E-mail: Limin.Qiu@zju.edu.cn
作者简介: 李卓裴（1981－），女，广西柳州人，博士生，从事斯特林型脉管制冷机研究．
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　

引用本文:

李卓裴,邱利民,刘国军,等. 热声发动机驱动的脉管制冷机模拟及实验研究[J]. J4, 2009, 43(8): 1458-1462.

LI Zhuo-Fei, QIU Li-Min, LIU Guo-Jun, et al. Simulation and experimental study of pulse tube cooler driven by thermoacoustic engine. J4, 2009, 43(8): 1458-1462.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2009.    或    http://www.zjujournals.com/eng/CN/Y2009/V43/I8/1458

[1] RADEBAUGH R, MCDERMOTT K M, SWIFT G W, et al. Development of a thermoacoustically driven orifice pulse tube refrigerator [C]∥ Proceedings of the 4th Interagency Meeting on Cryocoolers. Plymouth: Navy Report, 1991: 205-220.
[2] SWIFT G W. Thermoacoustic natural gas liquefier [C]∥ Proceedings of DOE Natural Gas Conference. Houston: [s.n.], 1997: 1-5.
[3] 孙大明,邱利民,严伟林,等. 行波热声发动机驱动的脉管制冷机研究[J]. 低温工程, 2005(1): 30-34.
SUN Da-ming, QIU Li-min, YAN Wei-lin, et al. Investigation on a pulse tube cooler driven by a traveling wave thermoacoustic engine [J]. Cryogenic Engineering, 2005(1): 30-34.
[4] QIU Li-min, SUN Da-ming, YAN Wei-lin, et al. Investigation on a thermoacoustically driven pulse tube cooler working at 80 K [J]. Cryogenics, 2005, 45(5): 380-385.
[5] TANG Ke, BAO Rui, CHEN Guo-bang, et al. Thermoacoustically driven pulse tube cooler below 60 K [J]. Cryogenics，2007, 47(9/10): 526-529.
[6] 胡剑英,戴巍,罗二仓. 40 K温区的热驱动低温热声制冷机[J]. 工程热物理学报, 2006, 27(2): 189-192.
HU Jian-ying, DAI-wei, LUO Er-cang. A 41 K heat-driven thermoacoustic cooler [J]. Journal of Engineering Thermophysics, 2006, 27(2): 189-192.
[7] HU Jian-ying, LUO Er-cang, DAI Wei. A thermoacoustically-driven single-stage pulse tube cryocooler operating below 35 K [C]∥ Proceedings of ICEC. Prague: ICEC, 2006: 493-496.
[8] HU Jian-ying, LUO Er-cang, DAI Wei, et al. A heat-driven thermoacoustic cryocooler capable of reaching below liquid hydrogen temperature [J]. Chinese Science Bulletin, 2007, 52(4): 574-576.
[9] GARY J, GALLAGHER A, RADEBAUGH R, et al. REGEN 3-2: user manual [M]. NIST, 2001.
[10] VANAPALLI S, LEWIS M, GAN Zhi-hua, et al. 120 Hz pulse tube cryocooler for fast cooldown to 50 K [J]. Applied Physics Letters 90, 2007: 072504.
[11] 邱利民,孙大明,张武,等. 大型多功能热声发动机的研制及初步实验. 第一部分:热声发动机的研制[J]. 低温工程, 2003(2): 1-7.
QIU Li-min, SUN Da-ming, ZHANG Wu, et al. study of a large-scale multi-function thermoacoustic heat engine with high efficiency. Part I: Design and construction of the engine [J]. Cryogenic Engineering, 2003(2): 1-7.
[12] 邱利民,孙大明. 大型多功能热声发动机的研制及初步实验. 第二部分:热声发动机的初步实验[J]. 低温工程, 2003(3): 1-6.
QIU Li-min, SUN Da-ming. Study of a large-sclae multi-function thermo-acoustic heat engine with high efficiency. Part II. Preliminary experiments on the engine [J]. Cryogenic Engineering, 2003(3): 1-6.
[13] SUN Da-ming, QIU Li-min, ZHANG Wu, et al. Investigation on traveling wave thermoacoustic heat engine with high pressure amplitude [J]. Energy Conversion and Management, 2005, 46(2): 281-291.
[14] HU Jian-ying, LUO Er-cang, DAI Wei. An innovative configuration for thermoacoustically-driven pulse tube coolers [J]. Cryogenics, 2005, 45(7): 523-527.
[1] 甘智华,吴英哲,袁园,邱利民,张学军,张小斌,徐旭. 120 Hz单级脉管制冷机理论与实验[J]. J4, 2011, 45(11): 2014-2019.
[2] 甘智华,范炳燕,陈杰,等. 35K两级高频脉管制冷研究：Ⅱ.实验验证[J]. J4, 2009, 43(8): 1454-1457.
[3] 甘智华,范炳燕,徐娜娜,等. 35K两级高频脉管制冷研究:Ⅰ.理论分析[J]. J4, 2009, 43(8): 1448-1453.