Please wait a minute...
工程设计学报
工程设计学报  2008, Vol. 15 Issue (2): 109-113    
工程设计理论、方法与技术     
GMA在脉冲喷射开关阀中的应用
 孟爱华1, 周建军1, 潘玉良1, 项占琴2
1. 杭州电子科技大学 机械工程学院,浙江 杭州 310018；
2. 浙江大学 现代制造工程研究所,浙江 杭州 310027
Application of GMA in pulsed jet on-ff valve
 MENG  Ai-Hua1, ZHOU  Jian-Jun1, PAN  Yu-Liang1, XIANG  Zhan-Qin2
1.College of Mechanical Engineering, Hangzhou Dianzi University, Hangzhou 310018, China;
2.Institute of Modern Manufacturing Engineering, Zhejiang University, Hangzhou 310027, China
 全文: PDF(428 KB)   HTML
摘要： 通过分析脉冲喷射开关阀的工作性能,提出致动器是决定脉冲喷射开关阀特性的关键因素.对比3种致动器的性能参数,指出GMA更适合脉冲喷射开关阀的工作要求.GMA的性能分析和仿真结果给出了在脉冲喷射开关阀中工作的GMA的静、动态特性.脉冲喷射开关阀单脉冲流量实验曲线表明：脉冲喷射开关阀的单脉冲流量随励磁电流的变化规律与GMA的磁致伸缩曲线特性相似,在GMA的磁致伸缩曲线的线性区即可满足单脉冲喷射流量要求.动态实验中,脉冲喷射开关阀的阀芯位移阶跃响应上升时间只有0.81 ms,远远满足脉冲喷射开关阀应用的工作频率要求.
关键词： GMA;  脉冲喷射开关阀;  超磁致伸缩;  致动器    
Abstract: Through analysis on working performance on pulsed jet on-off valve (PJOV), the conclusion that actuator is the key factor to determine the performance of such valve is drawn. By comparing the performance parameters of three actuators, it was concluded that GMA was the most suitable one for PJOV. Performance analysis and simulation result provided the static and dynamic properties of GMA in PJOV. Pulse flux experimental curve of PJOV indicates that changing rules of single-pulse flux with exciting currency is similar to curve property of magnetostriction of GMA, and the linear area of magnetostriction of GMA can fulfill the requirements of single-pulse jet flux. In dynamic experiments, the rising time of step response of valve stem was only 0.81 ms, which well fulfilled the requirements of PJOV.
Key words:  GMA    pulsed jet on-off valve    giant magnetostriction    actuator
出版日期: 2008-04-28
服务　　
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章　　
孟爱华
周建军
潘玉良
项占琴

引用本文:

孟爱华, 周建军, 潘玉良, 项占琴. GMA在脉冲喷射开关阀中的应用[J]. 工程设计学报, 2008, 15(2): 109-113.

MENG Ai-Hua, ZHOU Jian-Jun, PAN Yu-Liang, XIANG Zhan-Qin. Application of GMA in pulsed jet on-ff valve[J]. Chinese Journal of Engineering Design, 2008, 15(2): 109-113.

链接本文:

https://www.zjujournals.com/gcsjxb/CN/    或    https://www.zjujournals.com/gcsjxb/CN/Y2008/V15/I2/109

[1] 顾晓蕾, 唐志峰, 吕福在, 刘磊. 无源自适应磁流变阻尼器的磁场设计与研究[J]. 工程设计学报, 2011, 18(5): 386-390.
[2] 邬义杰, 徐杰. 超磁致伸缩执行器热误差补偿及抑制方法研究[J]. 工程设计学报, 2005, 12(4): 213-218.
[3] 邬义杰, 刘楚辉. 超磁致伸缩驱动器设计准则的建立[J]. 工程设计学报, 2004, 11(4): 187-191.
[4] 浦军, 梅德庆, 陈子辰. 超磁致伸缩微位移致动器的研究[J]. 工程设计学报, 2003, 10(5): 275-278.