Please wait a minute...
浙江大学学报(工学版)  2017, Vol. 51 Issue (11): 2276-2286    DOI: 10.3785/j.issn.1008-973X.2017.11.023
电气电子自动化     
考虑死区的三相PWM逆变器共模电压抑制技术
袁庆伟, 赵荣祥
浙江大学 电气工程学院, 浙江 杭州 310027
Common-mode voltage suppression algorithm for three-phase PWM inverter in consideration of dead-band
YUAN Qing-wei, ZHAO Rong-xiang
College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China
 全文: PDF(5055 KB)   HTML
摘要:

为了实现对三相脉宽调制(PWM)逆变器死区条件下输出共模电压尖峰的有效抑制,提出混合调制算法.分析死区对临近矢量PWM(NSPWM)和等效零矢量PWM(AZSPWM1)输出共模电压的影响,揭示共模电压尖峰出现时需满足的负载功率因数和所处的扇区位置.为了消除共模电压尖峰,限定有关电压矢量的最小作用时间,并根据伏秒平衡原理,分别对NSPWM和AZSPWM1进行修正.分别分析最小作用时间对修正的NSPWM和AZSPWM1适用调制范围的影响,并将二者结合组成混合调制算法.结果表明:该混合调制算法可在全功率因数条件下宽调制范围内实现对共模电压尖峰的有效抑制.

Abstract:

A hybrid modulation algorithm was proposed in order to eliminate the spikes incurred by the dead-band on the common-mode voltage (CMV) output of three-phase pulse with modulation (PWM) inverter. The CMV output variations for both near state PWM (NSPWM) and active zero PWM1 (AZSPWM1) involved with dead-band were analyzed. The regions in sectors and the related load power factor conditions when the CMV spikes emerge were deduced. The minimal time durations of the active voltage vectors were limited to eliminate the CMV spikes. Both the NSPWM and AZSPWM1 were modified according to the voltage-second integral principle. The influences brought by the limitations on the linear modulation range of both NSPWM and AZSPWM1 were analyzed respectively. Then the modified NSPWM and modified AZSPWM1 were combined as the hybrid modulation algorithm. The experimental results show that the CMV spikes caused by the dead-band are rejected by the proposed algorithm in full load power factor conditions and a wide linear modulation range.

收稿日期: 2016-10-17 出版日期: 2017-11-13
CLC:  TM464  
通讯作者: 赵荣祥,男,博导.ORCID:0000-0001-8744-7515.     E-mail: rongxiang@zju.edu.cn
作者简介: 袁庆伟(1988-),男,博士生,从事逆变器输出共模电压抑制等研究.ORCID:0000-0003-0293-1709.E-mail:yqw65111762@sina.com
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
作者相关文章  

引用本文:

袁庆伟, 赵荣祥. 考虑死区的三相PWM逆变器共模电压抑制技术[J]. 浙江大学学报(工学版), 2017, 51(11): 2276-2286.

YUAN Qing-wei, ZHAO Rong-xiang. Common-mode voltage suppression algorithm for three-phase PWM inverter in consideration of dead-band. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 2017, 51(11): 2276-2286.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2017.11.023        http://www.zjujournals.com/eng/CN/Y2017/V51/I11/2276

[1] 姜艳姝.现代变频调速系统负面效应研究及其对策[D].哈尔滨:哈尔滨理工大学,2007. JIANG Yan-shu. Research on adverse effects of modern pwm adjustable speed drive system and the associated countermeasures[D]. Harbin:Harbin University of Science and Technology, 2007.
[2] ERDMAN J M, KERKMAN R J, SCHLEGEL D W, et al. Effect of PWM inverters on AC motor bearing currents and shaft voltages[J]. IEEE Transactions on Industry Applications, 1996, 32(2):250-259.
[3] COSTELLO M J. Shaft voltages and rotating machinery[J]. IEEE Transactions on Industry Applications, 1993, 29(2):419-426.
[4] MACDONALD D, GRAY W. PWM drive related bearing failures[J]. IEEE Industry Applications Magazine, 1999, 5(4):41-47.
[5] 裴雪军,张凯,康勇,等.PWM逆变器共模干扰电流的衰减和抑制[J].中国电机工程学报, 2004, 24(11):80-84. PEI Xue-jun, ZHANG Kai, KANG Yong, et al. Damping and suppression of common mode interference currents in PWM inverter[J]. Proceedings of the CSEE, 2004, 24(11):80-84.
[6] 高强,徐殿国.PWM逆变器输出端共模与差模电压dv/dt滤波器设计[J].电工技术学报, 2007, 22(1):79-84. GAO Qiang, XU Dian-guo. Design of common-mode and differential-mode voltage dv/dt filter at PWM inverter output terminals[J]. Transactions of China Electrotechnical Society, 2007, 22(1):79-84.
[7] 陈希有,徐殿国,马洪飞,等.兼有共模电压抑制作用的逆变器输出无源滤波器[J].电工技术学报, 2002, 17(06):38-42. CHEN Xi-you, XU Dian-guo, MA Hong-fei, et al. The inverter output passive filter with the suppressing of common-mode voltage[J]. Transactions of China Electrotechnical Society, 2002, 17(06):38-42.
[8] 姜艳姝,徐殿国,刘宇,等.一种新颖的逆变器输出无源滤波器的研究(英文)[J].中国电机工程学报, 2004, 24(11):134-138. JIANG Yan-shu, XU Dian-guo, LIU Yu, et al. Research on a novel inverter output passive filter[J]. Proceedings of the CSEE, 2004, 24(11):134-138.
[9] VON J A, HAORAN Z, WALLACE A K. An evaluation of mitigation techniques for bearing currents, EMI and overvoltages in ASD applications[J]. IEEE Transactions on Industry Applications, 1998, 34(5):1113-1122.
[10] 姜艳姝,刘宇,徐殿国,等.PWM变频器输出共模电压及其抑制技术的研究[J].中国电机工程学报, 2005, 25(9):47-53. JIANG Yan-shu, LIU Yu, XU Dian-guo, et al. Research on common-mode voltage generated by a PWM inverter and its cancellation technology[J]. Proceedings of the CSEE, 2005, 25(9):47-53.
[11] 姜艳姝,陈希有,徐殿国,等.一种消除PWM逆变器驱动系统中电动机端轴电压和轴承电流的前馈有源滤波器[J]. 中国电机工程学报, 2003, 23(7):134-138. JIANG Yan-shu, CHEN Xi-you, XU Dian-guo, et al. A novel feed-forward-type active filter to eliminate shaft voltage and bearing current at motor terminal in a PWM inverter drives[J]. Proceedings of the CSEE, 2003, 23(7):134-138.
[12] 钟玉林,赵争鸣,袁立强.逆变器驱动电机的共模电压和轴电压的抑制[J].清华大学学报:自然科学版, 2009, 49(1):25-28. ZHONG Yu-lin, ZHAO Zheng-ming, YUAN Li-qiang. Suppression of common-mode and shaft voltages in inverter-driven induction motor[J]. Journal of Tsinghua University:Science and Technology, 2009, 49(1):25-28.
[13] ORITI G, JULIAN A L, LIPO T A. A new space vector modulation strategy for common mode voltage reduction[C]//PESC'97 Record. 28th Annual IEEE Power Electronics Specialists Conference. Saint Louis, MO:IEEE 1997.
[14] LAI Y S. New random technique of inverter control for common mode voltage reduction of inverter-fed induction motor drives[J]. IEEE Transactions on Energy Conversion, 1999, 14(4):1139-1146.
[15] CACCIATO M, CONSOLI A, SCARCELLA G, et al. Reduction of common-mode currents in PWM inverter motor drives[J]. IEEE Transactions on Industry Applications, 1999, 35(2):469-476.
[16] UN E, HAVA A M. A near-state PWM method with reduced switching losses and reduced common-mode voltage for three-phase voltage source inverters[J]. IEEE Transactions on Industry Applications, 2009, 45(2):782-793.
[17] HAVA A M, UN E. Performance analysis of reduced common-mode voltage PWM methods and comparison with standard PWM methods for three-phase voltage-source inverters[J]. IEEE Transactions on Power Electronics, 2009, 24(1):241-252.
[18] 陆海峰,瞿文龙,张星,等.抑制共模电压的不对称NZPWM技术[J]. 清华大学学报:自然科学版, 2007, 47(7):1122-1125. LU Hai-feng, QU Wen-long, ZHANG Xing, et al. Asymmetrical NZPWM technique for reducing the common-mode voltage[J]. Journal of Tsinghua University:Science and Technology, 2007, 47(7):1122-1125.
[19] 周娟,魏琛,杨宇,等.逆变器简化PWM算法及抑制共模电压策略[J].电工技术学报, 2014, 29(8):158-165. ZHOU Juan, WEI Chen, YANG Yu, et al. Inverter simplified algorithm of PWM and inhibit common-mode voltage strategy[J]. Transactions of China Electrotechnical Society, 2014, 29(8):158-165.
[20] HAVA A M, U X, N E. A high-performance PWM algorithm for common-mode voltage reduction in three-phase voltage source inverters[J]. IEEE Transactions on Power Electronics, 2011, 26(7):1998-2008.

[1] 宿紫鹏, 杨磊, 杨家强, 高敏. 基于开关表决策的APF与TSC混合系统投切控制方法[J]. 浙江大学学报(工学版), 2018, 52(11): 2201-2209.
[2] 李新, 肖龙, 刘国梁, 邵雨亭, 陈国柱. 基于相位补偿和交叉前馈补偿的VSG功率振荡抑制策略[J]. 浙江大学学报(工学版), 2018, 52(3): 569-576.