带有无损电流检测的高效率可重构DC-DC变换器

doi:10.3785/j.issn.1008-973X.2014.10.021

浙江大学学报(工学版)

计算机技术﹑电信技术

带有无损电流检测的高效率可重构DC-DC变换器

方瑜骅, 赵梦恋, 袁奋杰, 吴晓波

浙江大学超大规模集成电路设计研究所, 浙江杭州 310027

Reconfigurable high-efficiency DC-DC converter with lossless current-sensing technique

FANG Yu-hua, ZHAO Meng-lian, YUAN Fen-jie, WU Xiao-bo

Institute of VLSI Design, Zhejiang University, Hangzhou 310027, China

全文: PDF(2766 KB) HTML

摘要：

为了提高便携式设备供电电源的效率,提出可重构的高效率DC-DC变换器.针对锂电池供电电源的特点,采用绿色模式控制策略将变换器自动重构成3种模式,以实现升压和降压功能,并减小功耗.在轻载条件下引入突发控制模式,以减小开关损耗,从而提高了效率.变换器在1.5 μm BCD工艺下设计并流片,芯片面积为8.75 mm2.变换器的输入电压为2.7～4.2 V,输出电压为3.3 V.当输入电压接近3.3 V时,该系统可以实现降压和升压的平滑过渡.在快速响应的电流模式控制中,提出基于Gm-C滤波器的无损电流检测技术,实现了无损、精准的电流检测.当负载在30 mA和300 mA之间跳变时,系统恢复时间小于100 μs.在0～500 mA的负载范围内,系统的效率能够保持在80%以上,最高可达94%.

Abstract:

A reconfigurable high-efficiency DC-DC converter was proposed in order to improve the power efficiency of portable electric devices. A green-mode control strategy was developed to adaptively configure the converter into three modes based on the properties of Li-ion battery in order to achieve seamless step-up/down voltage conversion and minimize power loss. A burst mode control strategy was adopted at light load to reduce switching loss, and the power efficiency was improved. This converter was designed and fabricated in 1.5 μm BCD process, with a total chip area of 8.75 mm2. The input voltage can vary from 2.7 V to 4.2 V, and the output voltage is regulated at 3.3 V. The system can achieve seamless-transition between buck and boost when its input voltage approaches 3.3 V. A zero consumption current-sensing technique based on Gm-C filter was proposed to achieve lossless and accurate current sensing in fast-response current-mode controller. The recovery time for the system was less than 100 μs when its load steps were between 30 mA and 300 mA. The power efficiency of the system can maintain above 80% for 0-500 mA load range, and the peak value can be 94%.

出版日期: 2014-10-01

TN 433

基金资助:

浙江省自然科学基金资助项目(LY13F040001).

通讯作者: 赵梦恋,女,副教授 E-mail: zhaoml@vlsi.zju.edu.cn

作者简介: 方瑜骅(1989—),女,硕士生,从事模拟集成电路设计的研究.E-mail: fangyh@vlsi.zju.edu.cn

	服务
	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

引用本文:

方瑜骅, 赵梦恋, 袁奋杰, 吴晓波. 带有无损电流检测的高效率可重构DC-DC变换器[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2014.10.021.

FANG Yu-hua, ZHAO Meng-lian, YUAN Fen-jie, WU Xiao-bo.

Reconfigurable high-efficiency DC-DC converter with lossless current-sensing technique

. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2014.10.021.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2014.10.021 或 http://www.zjujournals.com/eng/CN/Y2014/V48/I10/1856

［1］ MA D, BONDADE R. Enabling power-efficient DVFS operations on silicon ［J］. IEEE Circuits and Systems Magazine, 2010, 10(1): 14-30.

［2］ MOHAN N, ROBBINS W P, IMBERTSON P, et al. Restructuring of first courses in power electronics and electric drives that integrates digital control ［J］. Power Electronics, 2003, 18(1): 429-437.

［3］ LOU J, WU X. Design of multi-mode 4-switch buck-boost controller ［C］∥ Proceedings of the 14th ACM/IEEE International Symposium Low Power Electronics and Design. San Francisco: ACM, 2009: 311-314.

［4］ LENK R. Application bulletin AB-20 optimum current-sensing techniques in CPU converters ［R］. USA: Fairchild Semiconductor, 1999.

［5］ PAUL R, DRAGAN M. Analysis of PWM nonlinearity in non-inverting buck-boost power converters ［C］∥ Power Electronics Specialists Conference. Rhodes: IEEE, 2008: 3741-3747.

［6］ PAUL R, DRAGAN M. Smooth transition and ripple reduction in 4-switch non-inverting buck-boost power converter for WCDMA RF power amplifier ［C］∥ International Symposium on Circuits and Systems. Seattle: IEEE, 2008: 3266-3269.

［7］ SANCHEZ-SINENCIO E, ANDREOU A. Low-voltage/low-power integrated circuits and systems ［M］. New York: IEEE, 1998.

［8］ LUO F, MA D. Design of digital tri-mode adaptive-output buck-boost power converter for power-efficient integrated systems ［J］. IEEE Transactions on Industrial Electronics, 2010, 57(6): 2151-2160.

［9］ SAHU B, RINCON-MORA G A. A high-efficiency, dual-mode, dynamic, buck-boost power supply IC for portable applications ［C］∥ Proceedings of the 18th International Conference on VLSI Design. Kolkata: IEEE, 2005: 858-861.

［10］ SAHU B, RINCON-MORA G A. A low voltage, dynamic, noninverting, synchronous buck-boost converter for portable applications ［J］. IEEE Transactions Power Electronics, 2004, 19(2): 443-452.

［11］ MURO K, NABESHIMA T, SATO T, et al. H-bridge buck-boost converter with dual feedforward control ［C］∥ Proceedings of the International Conference on 8th Power Electronics and Drive Systems. Taiwan: IEEE, 2009: 1002-1007.

[1]	代国定, 陈跃, 杨令, 袁政, 黄冲. 集成式斜波产生与求和电路的设计实现[J]. J4, 2013, 47(1): 83-87.
[2]	代国定,徐洋,李卫敏,黄鹏. 高性能分段温度曲率补偿基准电压源设计[J]. J4, 2010, 44(11): 2142-2147.
[3]	杨旸, 赵梦恋, 陆佳颖, 等. 高亮度白光LED驱动控制器设计[J]. J4, 2010, 44(1): 111-117.

Viewed

Full text

Abstract

Cited

Shared

Discussed