Effect of active carbon on microwave pyrolysis characteristics of petroleum sludge" /> 活性炭对储运油泥微波热解特性的影响
Please wait a minute...
浙江大学学报(工学版)
能源与机械工程     
活性炭对储运油泥微波热解特性的影响
潘志娟, 黄群星, Moussa-Mallaye Alhadj-Mallah, 王君, 池涌, 严建华
浙江大学 能源工程学系,浙江 杭州 310027
Effect of active carbon on microwave pyrolysis characteristics of petroleum sludge
PAN Zhi-juan, HUANG Qun-xing, Moussa-Mallaye Alhadj-Mallah, WANG Jun, CHI Yong, YAN Jian-hua
Department of Energy Engineering, Zhejiang University, Hangzhou 310027, China
 全文: PDF(1096 KB)   HTML
摘要:

为了提高油泥的热解效率并降低能耗,研究添加不同比例的活性炭对油泥微波热解过程及产物特性的影响,以活性炭作为吸波介质,着重利用气相色谱分析热解产物中的气相组分,利用GC-MS研究热解液相产物.首次完成对油泥热解过程中微波能量利用率的计算.结果发现:当微波辐照功率为800 W时,升温速率为23.4 ℃/min;添加吸波介质可以使热解的升温速率提高77%以上,热解产物中的固体残留率最多降低24.7%,气体产量最多提高46.9%.此外,不添加吸波介质时,油泥对微波能量的利用率为16.6%;而添加活性炭后,微波能量利用率可以提高12% 以上,并且随着活性炭添加量的增大,能量利用率提高.

Abstract:

The effect of activate carbon on the pyrolysis behavior of petroleum sludge under microwave irradiation was studied to improve the pyrolysis efficiency of sluge and reduce energy consumption. Activated carbon was taken as microwave absorber. Mainly, gas chromatography (GC) was applied to analyze the gas phase composition of pyrolysis products, and gas chromatograph-mass spectrometer (GC-MS) was used to study the pyrolysis liquid products. the utilization ratio of microwave energy in the process of sludge pyrolysis was calculated for the first time. Results showed that the heating rate of petroleum sludge was 23.4 ℃/min when the power of microwave irradiation was 800 W. Through adding microwave absorber, the heating rate of pyrolysis was increased by more than 77%. Meanwhile, solid residues decreased by up to 24.7%, and gas product increased by 46.9% at most. In addtion, without microwvae absorber, the microwave energy utilization of sluge was 16.6%. While it could be increased by more than 12% by adding active carbon. The microwave energy utilization could be improved with the increase of active carbon content.

出版日期: 2015-06-01
:  TK 121  
基金资助:

国家“973”重点基础研究发展规划资助项目(2011CB201506);国家“十二五”科技支撑计划资助项目(2012BAB09B03);国家“863”高技术研究发展计划资助项目(2012AA063505);浙江省创新团队基金资助项目(A2009R50049);浙江省自然科学基金资助项目(LY13E060003)

通讯作者: 黄群星,男,教授     E-mail: hqx@zju.deu.cn
作者简介: 潘志娟(1989—),女,硕士生,从事含油污泥微波热解研究.E-mail: pzj@zju.edu.cn
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

潘志娟, 黄群星, Moussa-Mallaye Alhadj-Mallah, 王君, 池涌, 严建华. 活性炭对储运油泥微波热解特性的影响[J]. 浙江大学学报(工学版), 10.3785/j.issn.1008-973X.2015.06.023.

PAN Zhi-juan, HUANG Qun-xing, Moussa-Mallaye Alhadj-Mallah, WANG Jun, CHI Yong, YAN Jian-hua.

Effect of active carbon on microwave pyrolysis characteristics of petroleum sludge
. JOURNAL OF ZHEJIANG UNIVERSITY (ENGINEERING SCIENCE), 10.3785/j.issn.1008-973X.2015.06.023.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2015.06.023        http://www.zjujournals.com/eng/CN/Y2015/V49/I6/1166

[1] 宋秀艳,周鑫宏;苏永新.国内外含油污泥的处理现状和发展前景[J].新疆石油科技, 2009, 19(02): 51-55.
SONG Xiu-yan, ZHOU Xin-hong, SU Yong-xin. The current situation and development prospect of oily sludge treatment at home and abroad[J]. Xinjiang Petroleum Science and Technology, 2009, 19(02): 51-55.
[2] 匡少平,吴信荣.含油污泥的无害化处理与资源化利用[M].北京:化学工业出版,2009: 219.
[3] HU G J, LI J B, ZENG G M. Recent development in the treatment of oily sludge from petroleum industry: a review [J]. Journal of Hazardous Materials, 2013, 261: 470490.
[4] 刘志群,白玉兴,黄春富.落地油泥污染及油土分离处理的工艺研究[J].环境保护科学, 2004, 30: 43-45.
LIU Zhi-qun, BAI Yu-xing, HUANG Chun-fu. Research on pollution of mixture consisted of crude oil and soil and technology of separated crude oil from the mixture[J]. Environmental Protection Science, 2004, 30: 43-45.
[5] 徐如良,韩子兴.油罐底泥的减量化和资源化技术[J].石油与天然汽化工,2004年, 33(5): 369-374.
XU Ru-liang, HAN Zi-xing. Reduction and regeneration technology of bottom sludge from oil tanks[J]. Chemical Engineering of Oil and Gas, 2004, 33(5): 369-374.
[6] 庞霞,张刚,李留仁,等.孤东采油厂含油泥砂理参数优选与机理分析研究[J].石油与天然汽化工, 2009, 38(1): 85-88.
PANG Xia, ZHANG Gang, LI Liu-reng, et al. Parameter optimization and mechanism analysis of processing oil-bearing sludge sand by hot water in gudong oil production plant [J]. Chemical Engineering of Oil and Gas, 2009, 38(1): 85-88.
[7] SCHEMIDT H, KAMINSKY W. Pyrolysis of oil sludge in a fluidised bed reactor [J]. Chemosphere, 2001, 45: 285-290.
[8] 宋薇,刘建国,聂永丰.含油污泥的热解特性研究[J].燃料化学学报,2008, 36(3): 286-290.
SONG Wei, LIU Jian-guo, NIE Yong-feng. Pyrolysis properties of oil sludge[J]. Journal of Fuel Chemistry and Technology, 2008, 36(3): 286-290.
[9] 金钦汉,戴树策,黄卡玛.微波化学[M].北京:科学出版社,1999: 16-18.
[10] 雍兴跃,张建,祝威,等.半干化含聚油泥的微波热处理过程研究 [J].石油与天然汽化工, 2010, 39(4): 354-359.
YONG Xing-yue, ZHANG Jian, ZHU Wei, et al. Microwave heat treatment process of half dried oil sludge containing PAC[J]. Chemical Engineering of Oil and Gas, 2010, 39(4): 354-359.
[11] 王万福,李果,雍兴跃,等.油泥微波程序升温热转化[J].化工进展, 2011, 30(10): 2310231.
WANG Wan-fu, LI Guo, YONG Xing-yue, etc. Microwave thermal inversion of oily sludge by programmed temperature increasing [J]. Progress in Chemical Industry, 2011, 30(10): 2310231.
[12] 王同华,胡俊生,夏莉,等.微波热解污泥及产物组成的分析[J].沈阳建筑大学学报:自然科学版, 2008, 24(4): 662-666.
WANG Tong-hua, HU Jun-sheng, XIA Li, et al. Pyrolysis of sewage sludge by microwave radiation[J]. Journal of Shenyang Jianzhu University: Natural Science, 2008, 24(4): 662-666.
[1] 任立波, 韩吉田, 赵红霞. 单沉浸管流化床内离散颗粒数值模拟[J]. 浙江大学学报(工学版), 2015, 49(1): 150-156.
[2] 楼彬, 徐旭, 王文龙, 王宇飞, 范利武, 俞自涛2. 水基碳纳米管纳米流体在矩形腔内的自然对流传热[J]. 浙江大学学报(工学版), 2014, 48(12): 2196-2201.
[3] 周昊,芮淼,岑可法. 多孔介质内流体流动的大涡格子Boltzmann方法研究[J]. J4, 2012, 46(9): 1660-1665.
[4] 徐何伟,周昊,岑可法. 红外反射法测量飞灰碳质量分数[J]. J4, 2011, 45(5): 890-895.
[5] 赵加佩, 周昊, 岑可法. 辐射废锅内高温高压合成气的辐射特性[J]. J4, 2010, 44(9): 1781-1786.
[6] 王辉, 骆仲泱, 蔡洁聪, 王涛, 赵佳飞, 倪明江. SiO2纳米流体透射率影响因素实验研究[J]. J4, 2010, 44(6): 1143-1148.