Please wait a minute...
J4  2013, Vol. 47 Issue (10): 1877-1882    DOI: 10.3785/j.issn.1008-973X.2013.10.026
环境与化学工程     
微气泡曝气中活性污泥混合液性质变化
马锦1, 刘春1, 张磊1, 张静1, 吴根2, 杨景亮1, 罗湘南1
1. 河北科技大学 环境科学与工程学院,河北 石家庄 050018;2. 科技部 基础研究管理中心,北京 100862
Variations of mixed liquor properties of activated sludge in microbubble aeration
MA Jin1, LIU Chun1, ZHANG Lei1, ZHANG Jing1, WU Gen2, YANG Jing-liang1,LUO Xiang-nan1
1. School of Environmental Science and Engineering, Hebei University of Science and Technology, Shijiazhuang 050018, China; 2. Basic Research Service Center, Ministry of Science and Technology, Beijing 100862, China
 全文: PDF  HTML
摘要:

采用SPG膜微气泡发生系统,考察微气泡曝气过程中,污泥混合液性质的变化及相关关系,包括污泥粒径、污泥EPS质量浓度、上清液浊度和有机碳质量浓度、混合液黏度和表面张力等.结果表明,在微气泡发生系统中液体循环泵的水力剪切作用造成污泥絮体破碎及污泥粒径减小.在该过程中,污泥EPS释放,上清液浊度和有机碳(特别是胶体有机碳)质量浓度升高,同时污泥絮体的再絮凝能力严重丧失.污泥EPS物质的释放导致混合液黏度增加,但混合液表面张力保持不变.相关性分析表明,污泥粒径减小及污泥EPS释放是造成混合液其他性质变化的主要原因.与离心型循环泵相比,蠕动泵水力剪切作用较弱,对混合液性质的影响较小.微气泡曝气中污泥混合液性质的变化会加速膜过滤过程的膜污染.

Abstract:

Variations of mixed liquor properties of activated sludge were investigated and their correlations were analyzed in microbubble aeration using SPG membrane microbubble generation system, including sludge size, sludge EPS mass concentration, turbidity and organic carbon in the supernatant, viscosity and surface tension of mixed liquor. Results showed that the strong shear stress caused by liquid recycling pump in the microbubble generation system led to sludge broken and subsequent sludge floc size decreasing. During the process of sludge broken, sludge EPS released, which was considered to be responsible for increased turbidity and organic carbon (especially colloidal organic carbon) mass concentration in the supernatant. The re-flocculation ability of sludge flocs also reduced significantly due to sludge EPS release. In addition, the viscosity of mixed liquor increased along with sludge EPS release, but the surface tension remained constant. The sludge size decreasing and sludge EPS release were the main reasons for variations of other mixed liquor properties, according to correlation analysis. Compared to centrifugal type pump, peristaltic type pump impacted on mixed liquor properties less due to its weaker hydraulic shear stress. The membrane fouling in the membrane filtration process was accelerated due to variations of mixed liquor properties in microbubble aeration.

出版日期: 2013-10-01
:  X 176  
基金资助:

国家自然科学基金资助项目(51008111);河北省应用基础研究计划重点基础研究资助项目(11966726D).

通讯作者: 刘春,男,副教授.     E-mail: liuchun@hebust.edu.cn
作者简介: 马锦(1987—),女,硕士生,从事废水生物处理技术的研究.E-mail: majin0712@163.com
服务  
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章  

引用本文:

马锦, 刘春, 张磊, 张静, 吴根, 杨景亮, 罗湘南. 微气泡曝气中活性污泥混合液性质变化[J]. J4, 2013, 47(10): 1877-1882.

MA Jin, LIU Chun, ZHANG Lei, ZHANG Jing, WU Gen, YANG Jing-liang,LUO Xiang. Variations of mixed liquor properties of activated sludge in microbubble aeration. J4, 2013, 47(10): 1877-1882.

链接本文:

http://www.zjujournals.com/eng/CN/10.3785/j.issn.1008-973X.2013.10.026        http://www.zjujournals.com/eng/CN/Y2013/V47/I10/1877

[1] AGARWAL A, NG W J, LIU Y. Principle and applications of microbubble and nanobubble technology for water treatment [J]. Chemosphere, 2011, 84(9): 1175-1180.

[2] SHIN W T, MIMNIRAN A, YIACOUMI S, et al. Ozonation using microbubbles formed by electric fields [J]. Separation and Purification Technology, 1999, 15(3): 271-282.

[3] CHU L B, YAN S T, XING X H, et al. Enhanced sludge solubilization by microbubble ozonation [J]. Chemosphere, 2008, 72(2): 205-212.

[4] LIU S, WANG Q H, MA H Z, et al. Effect of micro-bubbles on coagulation flotation process of dyeing wastewater [J]. Separation and Purification Technology, 2010, 71(3): 337-346.

[5] TAKAHASHI M, CHIBA K, LI P. Free-radical generation from collapsing microbubbles in the absence of a dynamic stimulus [J]. Journal of Physical Chemistry B, 2007, 111(6): 1343-1347.

[6] TRAVERS S M, LOVETT D A. Activated sludge treatment of abattoir wastewater—II: influence of dissolved oxygen concentration [J]. Water Research, 1984, 18(4): 435-439.

[7] LIU F, ZHAO C C, ZHAO D F, et al. Tertiary treatment of textile wastewater with combined media biological aerated filter (CMBAF) at different hydraulic loadings and dissolved oxygen concentrations [J]. Journal of Hazardous Materials, 2008, 160(1): 161-167.

[8] FAVOLLE Y, COCKX A, GILLOT S, et al. Oxygen transfer prediction in aeration tanks using CFD [J]. Chemical Engineering Science, 2007, 62(24): 7163-7171.

[9] TERASAKA K, HIRABAYASHI A, NISHINO T, et al. Development of microbubble aerator for waste water treatment using aerobic activated sludge [J]. Chemical Engineering Science, 2011, 66(44): 3172-3179.

[10] TAKAHASHI M, KAWAMURA T, YAMAMOTO Y, et al. Effect of shrinking microbubble on gas hydrate formation [J]. Journal of Physical Chemistry B, 2003, 107(10): 2171-2173.

[11] TAKAHASHI M. Potential of microbubbles in aqueous solutions: electrical properties of the gas-water interface [J]. Journal of Physical Chemistry B, 2005, 109(46): 21858-21864.

[12] CHU L B, YAN S T, XING X H, et al. Enhanced sludge solubilization by microbubble ozonation [J]. Chemosphere, 2008, 72(2): 205-212.

[13] KUKIZAKI M, GOTO M. Size control of nanobubbles generated from Shirasu-porous-glass (SPG) membranes [J]. Journal of Membrane Science, 2006, 281(1/2): 386-396.

[14] KUKIZAKI M, WADA T. Effect of the membrane wettability on the size and size distribution of microbubbles formed from Shirasu-porous-glass (SPG) membranes [J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2008, 317(1/2/3): 146154.

[15] KUKIZAKI M, FUJIMOTO K, KAI S, et al. Ozone mass transfer in an ozone-water contacting process with Shirasu porous glass (SPG) membranes: a comparative study of hydrophilic and hydrophobic membranes [J]. Separation and Purification Technology, 2010, 72(3): 347-356.

[16] WU J L, HUANG X. Effect of mixed liquor properties on fouling propensity in membrane bioreactors [J]. Journal of Membrane Science, 2009, 342(1/2): 88-96.

[17] 孙逸敏.利用SPSS软件分析变量间的相关性 [J].新疆教育学院学报, 2007, 23(2): 120-123.

SUN Yi-min. Analyze the correlation between the variables using SPSS software [J]. Journal of Xinjiang Education Institute, 2007, 23(2): 120-123.

[18] KUKIZAKI M, GOTO M. Spontaneous formation behavior of uniform-sized microbubbles from Shirasu porous glass (SPG) membranes in the absence of water-phase flow [J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2007, 296(1/2/3): 174-181.

[19] 欧阳科,谢珊.膜生物反应器的运行和膜污染特性[J].广东化工,2011,38(7): 54, 82-83.

OU-YANG Ke, XIE Shan. Membrane fouling characteristics and fouling control methods in membrane bioreactors [J]. Guangdong Chemical Industry, 2011, 38(7): 54, 82-83.

[20] 朱学峰,吴志超,王志伟,等.膜-生物反应器处理超市废水中污泥性质与膜污染关系分析[J].环境工程学报, 2011, 5(1): 60-64.

ZHU Xue-feng, WU Zhi-chao, WANG Zhi-wei, et al. Correlation between membrane fouling and characteristics of sludge in a membrane bioreactor treating wastewater from supermarket [J]. Chinese Journal of Environmental Engineering, 2011, 5(1): 60-64.

[21] 陈学民,唐玉霖,伏小勇.中空纤维膜生物反应器膜污染影响因素[J].净水技术,2011, 30(1): 33-38.

SHEN Xue-min, TANG Yu-lin, FU Xiao-yong. Membrane fouling factors of hollow fiber membrane in municipal wastewater treatment process [J]. Water Purification Technology, 2011, 30(1): 33-38.

[1] 乔华,陈伟球. 基于Arlequin方法的无网格法与有限元法耦合[J]. J4, 2011, 45(3): 526-530.
[2] 马俊科, 刘春,吴根,杨景亮,郭建博,李再兴. 工业化UASB厌氧颗粒污泥产氢产乙酸菌群分析[J]. J4, 2011, 45(3): 576-581.